Understanding & Reducing VOC’s in New Homes.
Building Healthy Homes by reducing the VOC's in the building products used to build the home.
John P. Lapotaire, CIEC
www.FloridaIAQ.com
Reducing VOC's in New Homes, John P. Lapotaire, CIEC - Microshield 4-4-2011
1. Building A Healthy Home
Understanding & Reducing VOC’s in New Homes
John P. Lapotaire, CIEC John@FloridaIAQ.com
Microshield IAQ 1
Lydia A. Lapotaire, CIEC Lydia@FloridaIAQ.com www.FloridaIAQ.com
2. 1 Introduction
2 Building a Healthy Home
3 Volatile Organic Compounds VOCs
4 Where do VOCs come from?
5 What levels of VOCs are safe?
5 What can I do about VOCs?
2 VOC Pictures
3 Questions & Discussion
Microshield IAQ 2 www.FloridaIAQ.com
4. Building a Healthy Home
• Today's Home Builders Build Green
• Today's Home Builders Sell Green
• A Healthy Home is
Tomorrow’s Green Home!
• So…… Now It’s Time to Build and Sell
Healthy Homes!
Microshield IAQ 4 www.FloridaIAQ.com
5. Building a Healthy Home
• There is nothing stopping Home Builders
from building a Healthy Home
• Building a Healthy Home starts with carful
selection of the products used to build the
home.
• Low VOC products are a must when
building a Healthy Home.
Microshield IAQ 5 www.FloridaIAQ.com
6. Building a Healthy Home
• The old adage “an ounce of prevention is
worth a pound of cure” applies when
building a Healthy Home.
• So remember to look for Low VOC or VOC
Free choices when purchasing building
products.
• Currently there are no standard labeling
system for VOCs, but many manufacturers
offer a Low or No VOC option.
Microshield IAQ 6 www.FloridaIAQ.com
7. Building a Healthy Home
• Formaldehyde, one of the best known
VOCs, is surprisingly common in new home
construction.
• Luckily, it happens to be one of the few
indoor air pollutants that can be readily
measured.
• Air monitoring is one approach that can
help prevent adverse effects of exposure to
volatile organic compounds.
Microshield IAQ 7 www.FloridaIAQ.com
8. Building a Healthy Home
• Many products merely claim to be “Low
VOC.”
• Everyone specifying and purchasing
products must actually find the products’
VOC content in grams per liter (g/L), which
is usually found on the product’s technical
data sheet or material safety data sheet.
Microshield IAQ 8 www.FloridaIAQ.com
9. Building a Healthy Home
• Compare the listed VOC number with VOC
limits listed for different uses determined by
– South Coast Air Quality Management
District (SCAQMD)
– Rule #1113 and Green Seal GS-11 and GS-
03.
• SCAQMD is the air pollution control agency
for all of Orange County and the urban
portions of Los Angeles, Riverside and San
Bernardino counties, the smoggiest region
of the U.S.
Microshield IAQ 9 www.FloridaIAQ.com
10. Building a Healthy Home
• When you shop around, you’ll see labels
indicating “Low-VOC” and “zero-VOC”
paints, meaning they contain a reduced
number of grams of VOC per liter
– (under 150 grams for low-VOC and
– under 5 for zero-VOC).
• The majority of common paint brands now
provide these kinds of alternatives
Microshield IAQ 10 www.FloridaIAQ.com
11. Building a Healthy Home
• Water-based wood finishes, such as
waterborne urethane or acrylic, also have
decreased toxic compounds, but still provide
comparable durability to their standard
counterparts.
• You can also find paint with recycled content
which keeps remainders out of the waste
stream, cuts down on new production, and
generally costs less.
Microshield IAQ 11 www.FloridaIAQ.com
12. Building a Healthy Home
• Many conventional interior grade composite
materials, like carbon fiber and engineered
wood, contain urea-formaldehyde binder,
which has been classified as a Toxic Air
Contaminant by the California Air Resources
Board due to its potential to cause cancer.
• It’s now fairly common to hear about
formaldehyde-free fiberboards, and those
are the ones you want to look for.
Microshield IAQ 12 www.FloridaIAQ.com
13. Volatile Organic Compounds
VOCs
• Volatile Organic Compounds (VOCs) are a
large group of carbon-based chemicals that
easily evaporate at room temperature.
• While most people can smell high levels of
some VOCs, other VOCs have no odor.
• Odor does not indicate the level of risk from
inhalation of this group of chemicals.
Microshield IAQ 13 www.FloridaIAQ.com
14. Volatile Organic Compounds
VOCs
There are thousands of different VOCs
produced and used in our daily lives. Some
common examples include:
• Acetone • Perchloroethylene
• Benzene • Toluene
• Ethylene glycol • Xylene
• Formaldehyde • 1,3-butadiene
• Methylene chloride
Microshield IAQ 14 www.FloridaIAQ.com
15. Where do VOCs come from?
Many products we have in our homes
release or “off-gas” VOCs. Some examples
of sources of VOCs are:
• Building Materials – Solvents
– Carpets and – Upholstery fabrics
adhesives – Varnishes
– Composite wood – Vinyl Floors
products – Structural
– Paints components
– Sealing caulks
Microshield IAQ 15 www.FloridaIAQ.com
16. Where do VOCs come from?
• Far too often the reason a product produces
excessive amounts of VOC’s is Miss-
Application of the product.
• All Building Products MUST be installed and
applied according to the manufacturers
specifications.
• Failure to follow the spec’s can lead to
increased levels of product emitted VOC’s
Microshield IAQ 16 www.FloridaIAQ.com
17. Where do VOCs come from?
• Home and Personal Care Products
– Air fresheners
– Air cleaners that produce ozone
– Cleaning and disinfecting chemicals
– Cosmetics
– Fuel oil, gasoline
– Moth balls
– Vehicle exhaust running a car in an attached
garage
Microshield IAQ 17 www.FloridaIAQ.com
18. Where do VOCs come from?
• Behaviors
– Cooking
– Dry-cleaning
– Hobbies
– Newspapers
– Non-electric space heaters
– Photocopiers
– Smoking
– Stored paints and chemicals
– Wood burning stoves
Microshield IAQ 18 www.FloridaIAQ.com
20. Where do VOCs come from?
• Studies have shown that the level of VOCs
indoors is generally two to five times higher
than the level of VOC’s outdoors.
• VOC concentrations in indoor air depend on
many factors, including the:
– Amount of VOCs in a product;
– Rate at which the VOCs are released;
– Volume of the air in the room/building;
– Ventilation rate or the area; and
– Outdoor concentrations of VOCs.
Microshield IAQ 20 www.FloridaIAQ.com
21. What levels of VOCs is safe?
• No standards have been set for VOCs in
non industrial settings.
• OSHA regulates formaldehyde, a specific
VOC, as a carcinogen.
• OSHA has adopted a Permissible Exposure
Level (PEL) of .75 ppm, and an action level
of 0.5 ppm.
• HUD has established a level of .4 ppm for
mobile homes. It is advisable to mitigate
formaldehyde that is present at levels higher
than 0.1 ppm.
Microshield IAQ 21 www.FloridaIAQ.com
22. What levels of VOCs are safe?
Microshield IAQ 22 www.FloridaIAQ.com
23. What levels of VOCs are safe?
Microshield IAQ 23 www.FloridaIAQ.com
24. What levels of VOCs are safe?
Microshield IAQ 24 www.FloridaIAQ.com
25. What levels of VOCs are safe?
• The best health protection measure is to
limit your exposure to products and
materials that contain VOCs when possible.
• If you think you may be having health
problems caused by VOCs, try reducing
levels in your home.
• If symptoms persist, consult with your doctor
to rule out other serious health conditions
that may have similar symptoms.
Microshield IAQ 25 www.FloridaIAQ.com
26. What levels of VOCs are safe?
• There are established Health Risk Values
(HRVs) for some individual VOCs.
• HRVs are “concentrations of chemicals or
defined mixtures of chemicals emitted to air
that are unlikely to pose a significant risk of
harmful effects when humans are exposed
to those concentrations over a specified
time.”
Microshield IAQ 26 www.FloridaIAQ.com
27. Are some people at greater risk
from VOC exposure than others?
• Persons with respiratory problems such as
asthma, young children, elderly, and
• persons with heightened sensitivity to
chemicals may be more susceptible to
irritation and illness from VOCs.
Microshield IAQ 27 www.FloridaIAQ.com
28. Low-VOC Products
• Cleaner indoor air quality as well as reduced
chemical emissions can be realized by
simply using Low or No VOC building
materials.
• Elevated levels of VOC’s in new homes
have been linked to
– eye and respiratory irritation,
– headaches,
– fatigue and
– other symptoms associated with “sick
building” syndrome.
Microshield IAQ 28 www.FloridaIAQ.com
29. Low-VOC Products
• Many commonly used building products,
such as
– Paints
– Varnishes
– Adhesives
– Carpets
– Cabinets
– Structural Components
Some of these products can emit a variety of
harmful chemicals into the air for months
after they have been applied.
Microshield IAQ 29 www.FloridaIAQ.com
30. Low-VOC Products
Products that emit VOCs include, but are
not limited to, the following:
• Paints • Air fresheners
• Paint thinner • Stored fuels
• Solvents • Dry-cleaned clothing
• Wood preservatives • Carpets
• Finishes • Caulks and sealants
• Aerosol sprays • Adhesives
• Cleaners and • Office furniture
disinfectants
Microshield IAQ 30 www.FloridaIAQ.com
31. What can I do about VOCs that
are in the homes I build?
• Although home screening kits (devices) are
available to measure total volatile organic
compounds (TVOC) levels they are of
limited use and won’t correct a VOC
problem.
• Instead of testing, the first step is to conduct
an inspection of your home for the common
sources of VOCs.
Microshield IAQ 31 www.FloridaIAQ.com
32. What can I do about VOCs homes
I build?
• Sources that may be problematic include
almost everything you use to build your
homes which tend to off-gas more VOC’s
when they are new.
• The primary sources include carpet, paint,
plastics structural components or
manufactured wood products.
• And don’t forget the cleaning products used
when your home is complete.
Microshield IAQ 32 www.FloridaIAQ.com
33. What can I do about VOCs that
are in the homes I build?
• Once you determine the probable source(s)
of VOCs, steps can be taken to reduce the
levels.
• If you are unable to determine probable
sources, a professional indoor air quality
investigator can be consulted.
Microshield IAQ 33 www.FloridaIAQ.com
34. What can I do about VOCs that
are in the homes I build?
• Source control: Remove or reduce the
number of products in the homes you build
that give off VOCs.
• Only purchase Low or No VOC Products
and carefully follow the manufacturers
spec’s on product labels.
Microshield IAQ 34 www.FloridaIAQ.com
35. What can I do about VOCs that
are in the homes I build?
• Remove unused building products from the
home immediately after use.
• stored chemicals in closed containers can
sometimes “leak” and release VOCs into
indoor air.
Microshield IAQ 35 www.FloridaIAQ.com
36. What can I do about VOCs that
are in the homes I build?
• Ventilation and climate control can be used
to reduce exposure to VOCs.
• Keep both the temperature and relative
humidity as low as possible or comfortable.
Chemicals will off-gas more under warmer
conditions with high humidity
Microshield IAQ 36 www.FloridaIAQ.com
37. What can I do about VOCs that
are in the homes I build?
• In summary, the most effective way to limit
VOCs indoors is to limit the potential
sources of VOCs.
• Increasing the amount of outdoor “fresh air”
into a space can also dilute and reduce
VOC levels.
Microshield IAQ 37 www.FloridaIAQ.com
38. Why Should You Use Low VOC
Building Materials?
• Reduced chemical emissions from VOCs.
• Improved indoor air quality.
• Improved occupant health.
• Reduced nuisance odor complaints
– eye and respiratory irritation, headaches,
fatigue and other symptoms of “sick
building” syndrome.
• Value-added appeal to Health Conscious
Home Buyers!
Microshield IAQ 38 www.FloridaIAQ.com
39. Photos of Building Products Emitting VOC’s
VOC’S PRODUCED FROM
BUILDING PRODUCTS
What is the Catalyst Causing the Building
Products to Emit the VOC’s
Microshield IAQ 39 www.FloridaIAQ.com