1. ZJ INDEX 1
Description Group-Page Description Group-Page Description Group-Page
- 4.0L, GENERATOR REMOVE/INSTALL . . . . . 8B-6 ACTUATOR DRIVE CIRCUIT, BLEND AIR AIR DOOR, RECIRCULATING . . . . . . . . . . . . 24-36
- 4.0L, STARTER REMOVE/INSTALL . . . . . . . 8B-4 DOOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24-24 AIR DOOR, TEMPERATURE / BLEND . . . . . . 24-37
- 4.0L, TORQUE . . . . . . . . . . . . . . . . . . . . . . . 8B-8 ACTUATOR DRIVE CIRCUIT, MODE DOOR . 24-24 AIR FLOW CHECK, THROTTLE BODY
- 5.2L, GENERATOR REMOVE/INSTALL . . . . . 8B-7 ACTUATOR, HEAT / DEFROST DOOR . . . . . . 24-37 MINIMUM . . . . . . . . . . . . . . . . . . . . . . . . . . 14-73
- 5.2L, STARTER REMOVE/INSTALL . . . . . . . 8B-5 ACTUATOR, PANEL / DEFROST DOOR . . . . 24-39 AIR GAP, SPEED SENSOR . . . . . . . . . . . . . . . 5-29
42RE AUTOMATIC TRANSMISSION . . . . . . . 21-36 ACTUATOR, RECIRCULATING AIR DOOR . . 24-36 AIR INLET/RECIRC DOOR ACTUATOR
42RE GENERAL SPECIFICATIONS . . . . . . . 21-372 ADJUSTER PLUG ASSEMBLY DRIVE CIRCUIT . . . . . . . . . . . . . . . . . . . . . . 24-24
42RE IN-VEHICLE SERVICE . . . . . . . . . . . . . 21-77 REPLACEMENT . . . . . . . . . . . . . . . . . . . . . . 19-27 AIR TEMPERATURE SENSOR, AMBIENT . . . 24-40
42RE OVERDRIVE UNIT OVERHAUL . . . . . 21-146 ADJUSTER/MOTORS, POWER SEAT . . . 8R-1,8R-2 AIR TEMPERATURE SENSOR, INTAKE . . 8W-30-4
42RE PRESSURE TEST SPECIFICATIONS . 21-373 ADJUSTER/MOTORS REMOVE/INSTALL, AIR TEMPERATURE SENSOR, INTAKE
42RE TORQUE SPECIFICATIONS . . . . . . . . 21-374 POWER SEAT . . . . . . . . . . . . . . . . . . . . . . . . 8R-4 MANIFOLD; FUEL SYSTEM . . . . . . . . 14-46,14-86
42RE TRANSMISSION DIAGNOSIS . . . . . . . 21-42 ADJUSTMENT AND INSTALLATION, AIR TEMPERATURE SENSOR, INTAKE
42RE TRANSMISSION OVERHAUL . . . . . . . 21-98 BRAKELIGHT SWITCH . . . . . . . . . . . . . . . . . . 5-62 MANIFOLD; IGNITION SYSTEMS . . . . 8D-25,8D-5
42RE TRANSMISSION/OVERDRIVE ADJUSTMENT, COMPASS VARIATION . . . . . . 8C-8 AIR TEMPERATURE, SENSOR
REMOVAL AND INSTALLATION . . . . . . . . . . 21-89 ADJUSTMENT, DOOR LATCH . . . . . . . . . . . . 23-18 RESISTANCE (OHMS)—COOLANT
46RH AUTOMATIC TRANSMISSION . . . . . 21-164 ADJUSTMENT, GEARSHIFT CABLE . 21-206,21-79 TEMPERATURE SENSOR/MANIFOLD . . . . . . 14-34
46RH GENERAL SPECIFICATIONS . . . . . . . 21-374 ADJUSTMENT, GLASS VERTICAL HEIGHT . . 23-11 AIR TEMPERATURE SENSOR, SENSOR
46RH IN-VEHICLE SERVICE . . . . . . . . . . . 21-204 ADJUSTMENT, HOOD . . . . . . . . . . . . . . . . . . 23-4 RESISTANCE (OHMS)—COOLANT
46RH OVERDRIVE UNIT OVERHAUL . . . . . 21-270 ADJUSTMENT, LIFTGATE . . . . . . . . . . . . . . . 23-22 TEMPERATURE SENSOR/INTAKE . . . . . . . . . 14-71
46RH PRESSURE TEST SPECIFICATIONS . 21-375 ADJUSTMENT, OVERDRIVE CLUTCH AIR TEMPERATURE SENSOR TEST,
46RH TORQUE SPECIFICATIONS . . . . . . . . 21-376 INSTALLATION . . . . . . . . . . . . . . . . . . . . . . 21-288 INTAKE MANIFOLD; FUEL SYSTEM . . 14-34,14-71
46RH TRANSMISSION DIAGNOSIS . . . . . . 21-170 ADJUSTMENT, OVERDRIVE UNIT AIR TEMPERATURE SENSOR TEST,
46RH TRANSMISSION OVERHAUL . . . . . . 21-223 ASSEMBLY . . . . . . . . . . . . . . . . . . . . . . . . . 21-155 INTAKE MANIFOLD; IGNITION
46RH TRANSMISSION/OVERDRIVE ADJUSTMENT, PARK INTERLOCK SYSTEMS . . . . . . . . . . . . . . . . . . . . . . . . . . 8D-12
REMOVAL—INSTALLATION . . . . . . . . . . . . 21-216 CABLE . . . . . . . . . . . . . . . . . . . . . 21-207,21-79 AIR TEMPERATURE SENSOR—PCM
4WD FRONT PROPELLER SHAFTS . . . . . . . . 16-1 ADJUSTMENT, PARKING BRAKE INPUT, INTAKE MANIFOLD . . . . . . . . 14-19,14-56
60-WAY CONNECTOR, POWERTRAIN TENSIONER . . . . . . . . . . . . . . . . . . . . . . . . . . 5-55 AIR TESTING TRANSMISSION CLUTCH
CONTROL MODULE (PCM) . . . . . . . . 14-32,14-69 ADJUSTMENT, PARKING BRAKESHOE . . . . . 5-58 AND BAND OPERATION . . . . . . . . . . 21-176,21-48
6-CYLINDER ENGINE, BELT TENSION— ADJUSTMENT, REAR WHEEL SENSOR AIRBAG CONTROL MODULE . . . . . . . . . . . . 8M-2
4.0L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-44 INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . 5-30
. AIRBAG CONTROL MODULE (ACM) . . . . 8W-43-1
6-CYLINDER ENGINE, CRANKCASE ADJUSTMENT, SHIFT LINKAGE . . 21-294,21-318, AIRBAG CONTROL MODULE REMOVE/
VENTILATION SYSTEM—4.0L . . . . . . . . . . . . 25-7 21-344 INSTALL . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8M-6
6-CYLINDER ENGINE, SERPENTINE ADJUSTMENT, TRANSFER CASE AIRBAG IMPACT SENSORS . . . . . . . . . . 8W-43-1
ACCESSORY DRIVE BELT ASSEMBLY . . . . . . . . . . . . . . . . . . . . . . . . . 21-360 AIRBAG MODULE . . . . . . . . . . . . . . . . . . . . . 8M-1
DIAGNOSIS—4.0L . . . . . . . . . . . . . . . . . . . . . 7-41 ADJUSTMENT, TRANSMISSION AIRBAG MODULE HANDLING . . . . . . . . . . . . 8M-4
8-CYLINDER ENGINE, SERPENTINE ASSEMBLY . . . . . . . . . . . . . . . . . . . . 21-137,21-22 AIRBAG MODULE REMOVE/INSTALL . . . . . . 8M-4
ACCESSORY DRIVE BELT ADJUSTMENT, TRANSMISSION AIRBAG SQUIB (AIRBAG IGNITER) . . . . . 8W-43-1
DIAGNOSIS—5.2L . . . . . . . . . . . . . . . . . . . . . 7-43 THROTTLE VALVE CABLE . . . . . . . . 21-205,21-78 AIRBAG SYSTEM . . . . . . . . . . . . . . . . . . . . . 8M-1
ABS BRAKE BLEEDING . . . . . . . . . . . . . . . . . 5-15 ADJUSTMENT USING ALIGNMENT AIRBAG SYSTEM CHECK . . . . . . . . . . . . . . . 8M-3
ABS BRAKE DIAGNOSIS . . . . . . . . . . . . . . . . . 5-3 SCREEN, HEADLAMP/FOG LAMP . . . . . . . . . 8L-6 AIRBAG SYSTEM SERVICE (DEPLOYED) . . . 8M-4
ABS BRAKES . . . . . . . . . . . . . . . . . . . . . . . . . . 5-1 ADJUSTMENT, VALVE BODY AIRBAG WARNING LAMP; AIRBAG
ABS PUMP MOTOR RELAY . . . . . . . . . . . 8W-32-1 SERVICE . . . . . . . . . . . . . . . . . . 21-121,21-247 SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . 8W-43-1
ABS SYSTEM OPERATION . . . . . . . . . . . . . . . 5-10 ADJUSTMENT—MINOR, DOOR AIRBAG WARNING LAMP; INSTRUMENT
ABS SYSTEM POWER-UP AND ALIGNMENT . . . . . . . . . . . . . . . . . . . . . . . . . 23-16 CLUSTER . . . . . . . . . . . . . . . . . . . . . . . . . 8W-40-3
INITIALIZATION . . . . . . . . . . . . . . . . . . . . . . . 5-12 ADJUSTMENTS, ALIGNMENT AIR-CONDITIONER COMPRESSOR . . . . . . . . 0-19
ABS SYSTEM RELAY . . . . . . . . . . . . . . . . 8W-32-1 MEASUREMENTS . . . . . . . . . . . . . . . . . . . . . . 2-5 AJAR DISPLAY, DOOR . . . . . . . . . . . . . . 8W-46-2
ABS WARNING LAMP; ANTI-LOCK ADJUSTMENTS, STEERING GEAR . . . . . . . . 19-22 AJAR DISPLAY, LIFTGATE . . . . . . . . . . . . 8W-46-2
BRAKES . . . . . . . . . . . . . . . . . . . . . . . . . 8W-32-2 ADJUSTMENTS, TRANSMISSION ALARM DIAGNOSIS (CONTINUED),
ABS WARNING LAMP; INSTRUMENT CONTROL CABLE . . . . . . . . . . . . . . . . . . . . 21-172 VEHICLE THEFT . . . . . . . . . . . . . . . . . . 8Q-4,8Q-5
CLUSTER . . . . . . . . . . . . . . . . . . . . . . . . . 8W-40-2 AFTERMARKET PAINT AND TRIM ALARM DIAGNOSIS, VEHICLE THEFT . . . . . . 8Q-3
ABS WARNING LIGHT DISPLAY . . . . . . . . . . . 5-3 REPAIR PRODUCTS . . . . . . . . . . . . . . . . . . . 23-44 ALARM SCHEMATIC (CONTINUED),
ABSOLUTE PRESSURE SENSOR, AIR CLEANER ELEMENT; EMISSION VEHICLE THEFT . . . . . . . . . . . . . . . . . . . . . . 8Q-11
MANIFOLD . . . . . . . . . . . . . . . . . . . . . . . 8W-30-4 CONTROL SYSTEMS . . . . . . . . . . . . . . . . . . 25-15 ALARM SCHEMATIC, VEHICLE THEFT . . . . 8Q-10
ABSORBER, SHOCK; FRONT AIR CLEANER ELEMENT; FUEL ALIGNMENT ADJUSTMENT—MINOR,
SUSPENSION AND AXLE . . . . . . . . . . . . . . . . 2-10 SYSTEM . . . . . . . . . . . . . . . . . . . . . 14-45,14-85 DOOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-16
ABSORBER, SHOCK; REAR SUSPENSION AIR CLEANER ELEMENT; LUBRICATION ALIGNMENT, HEADLAMP . . . . . . . . . . . . . . . 8L-6
AND AXLES . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-4 AND MAINTENANCE . . . . . . . . . . . . . . . . . . . 0-16 ALIGNMENT MEASUREMENTS AND
A/C COMPONENTS . . . . . . . . . . . . . . . . . . . . 24-2 AIR CLEANER HOUSING; EMISSION ADJUSTMENTS . . . . . . . . . . . . . . . . . . . . . . . . 2-5
A/C COMPRESSOR NOISE . . . . . . . . . . . . . . 24-27 CONTROL SYSTEMS . . . . . . . . . . . . . . . . . . 25-15 ALIGNMENT PREPARATION, HEADLAMP . . . 8L-6
A/C PERFORMANCE (TEMPERATURE AIR CLEANER HOUSING; FUEL ALIGNMENT, REAR AXLE . . . . . . . . . . . . . . . . 3-7
AND PRESSURE) . . . . . . . . . . . . . . . . . . . . . 24-11 SYSTEM . . . . . . . . . . . . . . . . . . . . . 14-45,14-85 ALIGNMENT SCREEN, HEADLAMP/FOG
A/C PERFORMANCE TEST . . . . . . . . . . . . . . . 24-9 AIR CONDITIONING (A/C) CLUTCH LAMP ADJUSTMENT USING . . . . . . . . . . . . . 8L-6
A/C REFRIGERANT OIL CAPACITIES . . . . . . 24-10 RELAY . . . . . . . . . . . . . . . . . . . . . . . . 14-46,14-86 ALIGNMENT SPECIFICATIONS . . . . . . . . . . . . . 2-7
ACCELERATION SWITCH; ANTI-LOCK AIR CONDITIONING (A/C) CLUTCH ALIGNMENT, WHEEL . . . . . . . . . . . . . . . . . . . . 2-4
BRAKES . . . . . . . . . . . . . . . . . . . . . . . . . 8W-32-1 RELAY—PCM OUTPUT . . . . . . . . . . . 14-23,14-59 ALUMINUM THREAD REPAIR . . . . . 21-215,21-87
ACCELERATION SWITCH; BRAKES . . . . . . . . 5-11 AIR CONDITIONING (A/C) CONTROLS— AMBIENT AIR TEMPERATURE SENSOR . . . 24-40
ACCELERATION SWITCH INSTALLATION . . . . 5-31 PCM INPUT . . . . . . . . . . . . . . . . . . . . 14-19,14-55 AMBIENT TEMPERATURE SENSOR . . . . . . . 24-25
ACCELERATION SWITCH OPERATION . . . . . . 5-14 AIR CONDITIONING COMPRESSOR . . . . . . 24-44 AMBIENT TEMPERATURE SENSOR
ACCELERATION SWITCH REMOVAL . . . . . . . 5-31 AIR CONDITIONING CYCLING SWITCH . . . . 24-16 REMOVE/INSTALL . . . . . . . . . . . . . . . . . . . . . 8C-9
ACCELERATOR PEDAL . . . . . . . . . . . . . . . . . 14-15 AIR CONDITIONING OPERATION . . . . . . 8W-42-1, AMPLIFIER AND SPEAKERS, POWER . . . 8W-47-1
8W-42-3 AMPLIFIER REMOVE/INSTALL . . . . . . . . . . . 8F-12
ACCELERATOR PEDAL AND THROTTLE AIR CONDITIONING SYSTEM . . . . . . . . . . . . 24-1
CABLE . . . . . . . . . . . . . . . . . . . 14-15,14-46,14-86 ANALYSIS, STALL TEST . . . . . . . . . 21-175,21-48
AIR CONDITIONING TEST PROCEDURES, ANALYZING THE ROAD TEST . . . . . 21-172,21-44
ACCESSORY DRIVE BELT DIAGNOSIS— HEATER . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24-13
4.0L 6-CYLINDER ENGINE, ANGLE, GROUND CLEARANCE AND
AIR CONTROL (IAC) MOTOR, IDLE; FUEL RAMP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0-11
SERPENTINE . . . . . . . . . . . . . . . . . . . . . . . . . 7-41 SYSTEM . . . . . . . . . . . . . . . . . . . . . . 14-49,14-90
ACCESSORY DRIVE BELT DIAGNOSIS— AIR CONTROL (IAC) MOTOR, IDLE; ANGLE MEASUREMENT, UNIVERSAL
4.0L ENGINE—CONTINUED, FUEL/IGNITION . . . . . . . . . . . . . . . . . . . . 8W-30-3 JOINT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16-5
SERPENTINE . . . . . . . . . . . . . . . . . . . . . . . . . 7-42 AIR CONTROL (IAC) MOTOR TEST, IDLE . . 14-75 ANTENNA . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8F-1
ACCESSORY DRIVE BELT DIAGNOSIS— AIR CONTROL (IAC) MOTOR—PCM ANTENNA, POWER . . . . . . . . . . . . . 8F-3,8W-47-2
5.2L 8-CYLINDER ENGINE, OUTPUT, IDLE . . . . . . . . . . . . . . . . . . 14-23,14-59 ANTENNA RELAY, POWER . . . . . . . . . . . . . . . 8F-3
SERPENTINE . . . . . . . . . . . . . . . . . . . . . . . . . 7-43 AIR CONTROL MOTOR TEST, IDLE . . . . . . . 14-36 ANTENNA RELAY REMOVE/INSTALL,
ACCESSORY DRIVE BELTS, ENGINE . . . . . . . 7-40 AIR DOOR ACTUATOR DRIVE CIRCUIT, POWER . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8F-15
ACCUMULATOR . . . . . . . . . . . . . . . . . . . . . . 24-43 BLEND . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24-24 ANTENNA REMOVE/INSTALL . . . . . . . . . . . . 8F-14
ACCUMULATOR OVERHAUL . . . . . . . . . . . 21-234 AIR DOOR ACTUATOR, RECIRCULATING . . 24-36 ANTILOCK BRAKING MODE, ABS
A/C-HEATER, MANUAL . . . . . . . . . . . . . . 8W-42-1 AIR DOOR MOTOR, BLEND . . . . . . . . . . 8W-42-2 OPERATION IN . . . . . . . . . . . . . . . . . . . . . . . 5-12
ACTUATOR DRIVE CIRCUIT, AIR AIR DOOR MOTOR, TEMPERATURE / ANTILOCK ECU AND HCU DIAGNOSIS . . . . . . 5-3
INLET/RECIRC DOOR . . . . . . . . . . . . . . . . . . 24-24 BLEND . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24-37 APPLICATION, BULB . . . . . . . . . . . . . . . . . . 8L-23

2. 2 INDEX ZJ
Description Group-Page Description Group-Page Description Group-Page
APPLIQUE/AIR EXHAUSTER, QUARTER BALL POWER STEERING GEAR, BLEEDING—BRAKELINES/HOSES, BRAKE
WINDOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-9 RECIRCULATING . . . . . . . . . . . . . . . . . . . . . 19-19 FLUID—BRAKE . . . . . . . . . . . . . . . . . . . . . . . 5-15
ARM BUSHINGS, LOWER AND UPPER BALL STUDS, STEERING KNUCKLE . . . . . . . 2-24 BLEND AIR DOOR ACTUATOR DRIVE
SUSPENSION . . . . . . . . . . . . . . . . . . . . . . . . . 0-24 BAND OPERATION, AIR TESTING CIRCUIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24-24
ARM, LOWER SUSPENSION; FRONT TRANSMISSION CLUTCH . . . . . . . . 21-176,21-48 BLEND AIR DOOR MOTOR . . . . . . . . . . . 8W-42-2
SUSPENSION AND AXLE . . . . . . . . . . . . . . . . . 2-9 BAND OVERHAUL, FRONT BLEND AIR DOOR MOTOR,
ARM, LOWER SUSPENSION; REAR SERVO . . . . . . . . . . . . . . . . . . . . 21-120,21-234 TEMPERATURE / . . . . . . . . . . . . . . . . . . . . . 24-37
SUSPENSION AND AXLES . . . . . . . . . . . . . . . . 3-4 BAND OVERHAUL, REAR SERVO . . . . . . . 21-120 BLEND AIR DOOR, TEMPERATURE / . . . . . . 24-37
ARM, PITMAN . . . . . . . . . . . . . . . . . . . . . . . 19-18 BAND SERVICE, LOW-REVERSE DRUM BLEND DOOR MOTOR . . . . . . . . . . . . . . 8W-42-4
ARM, UPPER SUSPENSION; FRONT AND REAR . . . . . . . . . . . . . . . . . . . . . . . . . 21-231 BLOCK, CYLINDER . . . . . . . . . . . . . . . . 9-44,9-73
SUSPENSION AND AXLE . . . . . . . . . . . . . . . . . 2-9 BAR, STABILIZER; FRONT SUSPENSION BLOCK HEATER, ENGINE . . . . . . . . . . . . . . . . 7-48
ARM, UPPER SUSPENSION; REAR AND AXLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-8 BLOWER MOTOR . . . . . . . . . . . 8W-42-1,8W-42-4
SUSPENSION AND AXLES . . . . . . . . . . . . . . . . 3-4 BAR, STABILIZER; REAR SUSPENSION BLOWER MOTOR ELECTRICAL
ARMING . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8Q-1 AND AXLES . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-3 DIAGNOSIS . . . . . . . . . . . . . . . . . . . . . . . . . 24-14
ARMS AND PUSH RODS, ROCKER . . . . 9-18,9-52 BAR, TRACK; FRONT SUSPENSION AND BLOWER MOTOR RESISTOR . . . . . . . . . . . . 24-33
ASSIST HANDLE . . . . . . . . . . . . . . . . . . . . . 23-35 AXLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-8 BLOWER SPEED VARIATIONS,
ATC DIAGNOSTICS . . . . . . . . . . . . . . . . . . . 24-17 BAR, TRACK; REAR SUSPENSION AND ATC-TEMPERATURE . . . . . . . . . . . . . . . . . . . 24-17
ATC SENSORS . . . . . . . . . . . . . . . . . . . . . . . . 24-3 AXLES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-3 BLOWER/FAN CONTROL, FRONT PANEL . . . 24-25
ATC-TEMPERATURE AND BLOWER BASE COAT/CLEAR COAT FINISH . . . . . . . . 23-43 BODY CLEANING AND INSPECTION,
SPEED VARIATIONS . . . . . . . . . . . . . . . . . . 24-17 BATTERY; BATTERY/STARTER/ VALVE . . . . . . . . . . . . . . . . . . . . . . 21-129,21-254
AUDIO SYSTEM CONNECTORS . . . . . . . . . . . 8F-4 GENERATOR SERVICE . . . . . . . . . . . . . . . . . . 8B-1 BODY CODE DECODING . . . . . . . . . . . . . . Intro.-4
AUTO HEADLAMP MODULE . . . . . . . . . . 8W-50-2 BATTERY; BATTERY/STARTING/ BODY CODE PLATE . . . . . . . . . . . . . . . . . . Intro.-3
AUTO HEADLAMP SYSTEM CHECK . . . . . . . 8L-17 CHARGING SYSTEMS DIAGNOSTICS . . . . . . 8A-3 BODY COMPONENTS . . . . . . . . . . . . . . . . . . . 0-26
AUTO HEADLAMP SYSTEM DIAGNOSIS . . . 8L-18 BATTERY; LUBRICATION AND BODY COMPONENTS, CHASSIS . . . . . . . . . . 0-24
AUTO HEADLAMPS . . . . . . . . . . . . . . . . . . . 8L-16 MAINTENANCE . . . . . . . . . . . . . . . . . . . . . . . 0-18 BODY LUBRICANT SPECIFICATIONS . . . . . . . 0-27
AUTO SHUTDOWN (ASD) RELAY—PCM BATTERY CHARGING . . . . . . . . . . . . . . . . . . . 8A-8 BODY MINIMUM AIR FLOW CHECK,
OUTPUT . . . . . . . . . . . . . . . . . . . . . . . 14-23,14-60 BATTERY CHARGING TIME TABLE . . . . . . . . 8A-8 THROTTLE . . . . . . . . . . . . . . . . . . . . . . . . . . 14-73
AUTOMATIC BELT TENSIONER—5.2L BATTERY CLASSIFICATIONS AND BODY SERVICE AND ADJUSTMENT,
ENGINE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-46 RATINGS . . . . . . . . . . . . . . . . . . . . . . . . . . . 8A-22 VALVE . . . . . . . . . . . . . . . . . . . . . . 21-121,21-247
AUTOMATIC DAY/NIGHT MIRROR . . . . . . 8T-1,8T-2 BATTERY DIAGNOSIS . . . . . . . . . . . . . . . . . . 8A-5 BODY SIDE CLADDING . . . . . . . . . . . . . . . . . 23-8
AUTOMATIC DAY/NIGHT MIRROR BATTERY FEED . . . . . . . . . . . . . . . . . . . . 8W-30-2 BODY STRIPES/DECALS . . . . . . . . . . . . . . . . 23-8
REMOVE/INSTALL . . . . . . . . . . . . . . . . . . . . . 8T-6 BATTERY RATINGS . . . . . . . . . . . . . . . . . . . . 8A-3 BOLT IDENTIFICATION . . . . . . . . . . . . . . Intro.-10
AUTOMATIC SHUT DOWN (ASD) RELAY . 8W-30-1 BATTERY REMOVE/INSTALL . . . . . . . . . . . . . 8B-1 BOLT STRENGTH . . . . . . . . . . . . . . . . . . Intro.-11
AUTOMATIC SHUTDOWN (ASD) RELAY; BATTERY SPECIFICATIONS; BATTERY/ BOOST VALVE . . . . . . . . . . . . . . . . . . . . . . 21-168
FUEL SYSTEM . . . . . . . . . . . . . . . . . . 14-46,14-86 STARTER/GENERATOR SERVICE . . . . . . . . . . 8B-8 BOOSTER CHECK VALVE TEST, POWER
AUTOMATIC SHUTDOWN (ASD) RELAY; BATTERY SPECIFICATIONS; BATTERY/ BRAKE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-8
IGNITION SYSTEMS . . . . . . . . . . 8D-17,8D-1,8D-6 STARTING/CHARGING SYSTEMS BOOSTER INSTALLATION, POWER
AUTOMATIC SHUTDOWN (ASD) RELAY DIAGNOSTICS . . . . . . . . . . . . . . . . . . . . . . . 8A-22 BRAKE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-27
TESTING . . . . . . . . . . . . . . . . . . . . . . 14-34,14-71 BATTERY TRAY . . . . . . . . . . . . . . . . . . . . . . . 23-6 BOOSTER OPERATION, POWER BRAKE . . . . 5-19
AUTOMATIC SHUTDOWN (ASD) BATTERY VOLTAGE—PCM INPUT . . . 14-19,14-55 BOOSTER REMOVAL, POWER BRAKE . . . . . . 5-26
SENSE—PCM INPUT . . . . . . . . . . . . . 14-19,14-55 BEAM INDICATOR LAMP, HIGH . . . . . . . 8W-40-2 BOOSTER VACUUM TEST, POWER
AUTOMATIC TEMPERATURE CONTROL . 8W-42-3 BEARING AND AXLE SHAFT, HUB . . . . . . . . . 2-19 BRAKE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-9
AUTOMATIC TEMPERATURE CONTROL BEARING, AXLE SHAFT SEAL . . . . . . . . . . . . 3-13 BOOSTER—COMBINATION VALVE—HCU,
(ATC) MODULE . . . . . . . . . . . . . . . . . . . . 8W-42-3 BEARING FITTING CHART, CONNECTING MASTER CYLINDER—BRAKE . . . . . . . . . . . . 5-18
AUTOMATIC TRANSMISSION . . . . . . . . . . . . 0-21 ROD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-36 BOOT REPLACEMENT, SPLASH
AUTOMATIC TRANSMISSION, 42RE . . . . . . 21-36 BEARING FITTING CHART, MAIN . . . . . . . . . . 9-43 SHIELD/CALIPER BRACKET/LEVER . . . . . . . . 5-59
AUTOMATIC TRANSMISSION, 46RH . . . . . 21-164 BEARING LUBRICANTS, CHASSIS BOX LAMP, GLOVE . . . . . . . . . . . . . . . . . 8W-44-2
AUTOMATIC TRANSMISSION OIL COMPONENT AND WHEEL . . . . . . . . . . . . . . 0-24 B-PILLAR TRIM PANEL, LOWER . . . . . . . . . 23-33
COOLERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-38 BEARING NOISE, GEAR; FRONT BRACKET, ADJUSTMENT . . . . . . . . . . . . . . . 23-12
AUTOMATIC TRANSMISSION SHIFTER/ SUSPENSION AND AXLE . . . . . . . . . . . . . . . . 2-12 BRACKET/LEVER BOOT REPLACEMENT,
IGNITION INTERLOCK MECHANISM . . . . . . 19-40 BEARING NOISE, GEAR; REAR SPLASH SHIELD/CALIPER . . . . . . . . . . . . . . . 5-59
AX 15 MANUAL TRANSMISSION . . . . . . . . . 21-1 SUSPENSION AND AXLES . . . . . . . . . . . . . . . . 3-6 BRAKE BLEEDING, ABS . . . . . . . . . . . . . . . . . 5-15
AX-15 TORQUE SPECIFICATIONS . . . . . . . 21-372 BEARING REPLACEMENT, PILOT . . . . . . . . . . 6-12 BRAKE BOOSTER CHECK VALVE TEST,
AXLE (2WD), MODEL 30 AXLE AND BEARING REPLACEMENT, PITMAN POWER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-8
TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-16 SHAFT SEALS . . . . . . . . . . . . . . . . . . . . . . . 19-32 BRAKE BOOSTER INSTALLATION,
AXLE (2WD VEHICLES), TUBE . . . . . . . . . . . . 2-3 BEARING REPLACEMENT, RELEASE . . . . . . . 6-11 POWER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-27
AXLE ALIGNMENT, REAR . . . . . . . . . . . . . . . . 3-7 BEARINGS, CRANKSHAFT MAIN . . . . . . 9-40,9-71 BRAKE BOOSTER OPERATION, POWER . . . . 5-19
AXLE AND TUBE AXLE (2WD), MODEL BEARINGS, FRONT WHEEL . . . . . . . . . . . . . . 0-24 BRAKE BOOSTER REMOVAL, POWER . . . . . . 5-26
30 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-16 BELT DIAGNOSIS . . . . . . . . . . . . . . . . . . . . . . 7-40 BRAKE BOOSTER VACUUM TEST,
AXLE ASSEMBLY REPLACEMENT . . . . . . . . . 3-10 BELT DIAGNOSIS—4.0L 6-CYLINDER POWER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-9
AXLE ASSEMBLY REPLACEMENT, DRIVE . . . 2-16 ENGINE, SERPENTINE ACCESSORY BRAKE CHECK, PRELIMINARY . . . . . . . . . . . . 5-4
AXLE BUSHING REPLACEMENT . . . . . . . 2-26,2-9 DRIVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-41 BRAKE COMPONENT INSPECTION . . . . . . . . . 5-5
AXLE, FRONT DRIVE . . . . . . . . . . . . . . . . . . . . 2-2 BELT DIAGNOSIS—4.0L ENGINE— BRAKE COMPONENTS, WHEEL . . . . . . . . . . . . 5-1
AXLE, MODEL 30 . . . . . . . . . . . . . . . . . . . . . 2-39 CONTINUED, SERPENTINE ACCESSORY BRAKE DIAGNOSIS, ABS . . . . . . . . . . . . . . . . . 5-3
AXLE, MODEL 35 . . . . . . . . . . . . . . . . . 3-10,3-32 DRIVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-42 BRAKE DIAGNOSIS, PARKING . . . . . . . . . . . . . 5-7
AXLE NOISE/VIBRATION DIAGNOSIS; BELT DIAGNOSIS—5.2L 8-CYLINDER BRAKE DIAGNOSIS, SERVICE . . . . . . . . . . . . . 5-4
FRONT SUSPENSION AND AXLE . . . . . . . . . . 2-12 ENGINE, SERPENTINE ACCESSORY BRAKE FLUID CONTAMINATION . . . . . . . . . . . 5-6
AXLE NOISE/VIBRATION DIAGNOSIS; DRIVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-43 BRAKE FLUID, RECOMMENDED . . . . . . . . . . 5-15
REAR SUSPENSION AND AXLES . . . . . . . . . . 3-6 BELT INDICATOR WARNING LAMP, SEAT . 8W-40-2 BRAKE FLUID/LUBRICANTS/CLEANING
AXLE, REAR . . . . . . . . . . . . . . . . . . . . . . . . . . 3-1 BELT SCHEMATICS . . . . . . . . . . . . . . . . . . . . 7-44 SOLVENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-2
AXLE SHAFT . . . . . . . . . . . . . . . . . . . . . . . . . 3-13 BELT, SERPENTINE DRIVE . . . . . . . . . . . . . . . 0-19 BRAKE FLUID—BRAKE BLEEDING—
AXLE SHAFT, HUB BEARING . . . . . . . . . . . . . 2-19 BELT SERVICE . . . . . . . . . . . . . . . . . . . . . . . . 7-44 BRAKELINES/HOSES . . . . . . . . . . . . . . . . . . . 5-15
AXLE SHAFT OIL SEALS . . . . . . . . . . . . . . . . 2-26 BELT SWITCH, DRIVER’S SEAT . . . . . . . . . . 8U-2 BRAKE NOISE . . . . . . . . . . . . . . . . . . . . . . . . . 5-7
AXLE SHAFT SEAL AND BEARING . . . . . . . . 3-13 BELT TENSION, DRIVE . . . . . . . . . . . . . . . . . 7-50 BRAKE PEDAL AND BRAKELIGHT
AXLE SHAFT— CARDAN U-JOINT . . . . . . . . . 2-20 BELT TENSION SPECIFICATIONS . . . . . . . . . . 7-44 SWITCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-61
AXLE SHAFT— CV-JOINT . . . . . . . . . . . . . . . 2-21 BRAKE PEDAL INSTALLATION . . . . . . . . . . . . 5-61
BELT TENSIONER—5.2L ENGINE, BRAKE PEDAL REMOVAL . . . . . . . . . . . . . . . 5-61
AXLE SPECIFICATIONS; FRONT AUTOMATIC . . . . . . . . . . . . . . . . . . . . . . . . . . 7-46 BRAKE PULL . . . . . . . . . . . . . . . . . . . . . . . . . . 5-6
SUSPENSION AND AXLE . . . . . . . . . . . . . . . . 2-39 BELT TENSION—4.0L 6-CYLINDER BRAKE SAFETY PRECAUTIONS . . . . . . . . . . . . 5-2
AXLE SPECIFICATIONS; REAR ENGINE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-44 BRAKE SWITCH . . . . . . . . . . . . . . . . . 14-46,14-86
SUSPENSION AND AXLES . . . . . . . . . . . . . . . 3-32 BELT TENSION—5.2L 8-CYLINDER BRAKE SWITCH INPUT; ANTI-LOCK
AXLES, FRONT AND REAR . . . . . . . . . . . . . . 0-22 ENGINE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-44 BRAKES . . . . . . . . . . . . . . . . . . . . . . . . . 8W-32-2
B AND C-PILLAR TRIM COVERS . . . . . . . . . 23-35 BELT/BUCKLE, FRONT SHOULDER . . . . . . . 23-37 BRAKE SWITCH INPUT; FUEL/IGNITION . 8W-30-5
B — INFINITY, CHART . . . . . . . . . . . . . . . . . . 8F-7 BELT/BUCKLE, REAR SHOULDER/LAP . . . . . 23-37 BRAKE SWITCH—PCM INPUT . . . . . 14-19,14-55
B — NON-INFINITY, CHART A . . . . . . . . . . . . 8F-8 BELTS, ENGINE ACCESSORY DRIVE . . . . . . . 7-40 BRAKE SYSTEM, POWER . . . . . . . . . . . . . . . 0-25
BACKUP LAMPS . . . . . . . . . . . . . . . . . . . . . . 8L-9 BENCH BLEEDING, MASTER CYLINDER . . . . 5-23 BRAKE TENSIONER ADJUSTMENT,
BACK-UP LAMPS . . . . . . . . . . . . . . . . . . 8W-51-1 BLEEDING, ABS BRAKE . . . . . . . . . . . . . . . . . 5-15 PARKING . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-55
BALANCE, TIRE AND WHEEL . . . . . . . . . . . . 22-6 BLEEDING, MASTER CYLINDER BENCH . . . . 5-23 BRAKE TORQUE SPECIFICATIONS . . . . . . . . . 5-63

3. ZJ INDEX 3
Description Group-Page Description Group-Page Description Group-Page
BRAKE WARNING LAMP . . . . . . . . . . . . . 8W-40-2 CALIPER DISASSEMBLY AND CENTER TONE LINE, VEHICLE
BRAKE WARNING LIGHT OPERATION, OVERHAUL, REAR . . . . . . . . . . . . . . . . . . . . . 5-43 INFORMATION . . . . . . . . . . . . . . . . . . . . . . . . 8U-2
SERVICE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-5 CALIPER INSTALLATION, FRONT . . . . . . . . . 5-39 CENTER, VEHICLE INFORMATION;
BRAKE WARNING LIGHTS . . . . . . . . . . . . . . . . 5-2 CALIPER INSTALLATION, REAR . . . . . . . . . . 5-46 INSTRUMENT PANEL AND GAUGES . . 8E-11,8E-4
BRAKELIGHT SWITCH ADJUSTMENT CALIPER OPERATION AND WEAR CENTER, VEHICLE INFORMATION;
AND INSTALLATION . . . . . . . . . . . . . . . . . . . 5-62 COMPENSATION . . . . . . . . . . . . . . . . . . . . . . 5-33 MESSAGE CENTER . . . . . . . . . . . . . . . . . 8W-46-1
BRAKELIGHT SWITCH, BRAKE PEDAL . . . . . 5-61 CALIPER OPERATION AND WEAR CENTERING, CLOCKSPRING . . . . . . . . . . . . . 8M-8
BRAKELIGHT SWITCH REMOVAL . . . . . . . . . 5-62 COMPENSATION, REAR . . . . . . . . . . . . . . . . . 5-41 CERTIFICATION LABEL, VEHICLE SAFETY . Intro.-3
BRAKELIGHT SWITCH TEST AND CALIPER REMOVAL, FRONT . . . . . . . . . . . . . 5-36 CHAIN AND SPROCKETS, TIMING . . . . . . . . 9-26
DIAGNOSIS . . . . . . . . . . . . . . . . . . . . . . . . . . 5-62 CALIPER REMOVAL, REAR . . . . . . . . . . . . . . 5-43 CHAIN COVER, TIMING . . . . . . . . . . . . . . . . . 9-58
BRAKELINES AND HOSES . . . . . . . . . . . . . . . 5-16 CAM AND LEVER REPLACEMENT . . . . . . . . . 5-58 CHANGE AND FILTER REPLACEMENT,
BRAKELINING, CONTAMINATED . . . . . . . . . . . 5-6 CAMSHAFT . . . . . . . . . . . . . . . . . . . . . . 9-27,9-60 ENGINE OIL . . . . . . . . . . . . . . . . . . . . . . . . . . 0-15
BRAKELINING MATERIAL . . . . . . . . . . . . . . . . 5-2 CAMSHAFT PIN REPLACEMENT . . . . . . . . . . 9-29 CHANGE, FLUID AND FILTER . . . . . . . . . . . 21-77
BRAKES, ABS . . . . . . . . . . . . . . . . . . . . . . . . . 5-1 CAMSHAFT POSITION SENSOR; FUEL CHANGE, LUBRICANT; FRONT
BRAKES, FRONT DISC . . . . . . . . . . . . . . . . . . 5-33 SYSTEM . . . . . . . . . . . . . . . . . . . . . . 14-46,14-86 SUSPENSION AND AXLE . . . . . . . . . . . . . . . . 2-17
BRAKES, PARKING . . . . . . . . . . . . . . . . . . . . 5-51 CAMSHAFT POSITION SENSOR; CHANGE, LUBRICANT; REAR
BRAKES, REAR DISC . . . . . . . . . . . . . . . . . . . 5-41 FUEL/IGNITION . . . . . . . . . . . . . . . . . . . . 8W-30-3 SUSPENSION AND AXLES . . . . . . . . . . . . . . . 3-11
BRAKESHOE INSTALLATION, FRONT . . . . . . . 5-35 CAMSHAFT POSITION SENSOR; CHARGING, BATTERY . . . . . . . . . . . . . . . . . . 8A-8
BRAKESHOE INSTALLATION, PARKING . . . . . 5-57 IGNITION SYSTEMS . . . . . . . . . . . . . . 8D-17,8D-2 CHARGING REFRIGERANT SYSTEM . . . . . . . 24-7
BRAKESHOE INSTALLATION, REAR . . . . . . . . 5-42 CAMSHAFT POSITION SENSOR TEST; CHARGING SYSTEM; BATTERY/
BRAKESHOE REMOVAL, FRONT . . . . . . . . . . 5-34 FUEL SYSTEM . . . . . . . . . . . . . . . . . . . . . . . 14-34 STARTING/CHARGING SYSTEMS
BRAKESHOE REMOVAL, PARKING . . . . . . . . 5-56 CAMSHAFT POSITION SENSOR TEST; DIAGNOSTICS . . . . . . . . . . . . . . . . . . . . . . . 8A-17
BRAKESHOE REMOVAL, REAR . . . . . . . . . . . 5-41 IGNITION SYSTEMS . . . . . . . . . . . . . . . . . . . 8D-6 CHARGING SYSTEM; CHARGING
BRAKESHOE REPLACEMENT, PARKING . . . . 5-56 CAMSHAFT POSITION SENSOR TESTING . . 14-71 SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . 8W-20-1
BRAKING MODE, ABS OPERATION IN CAMSHAFT POSITION SENSOR—PCM CHARGING SYSTEM DIAGNOSIS . . . . . . . . 8A-18
NORMAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-12 INPUT . . . . . . . . . . . . . . . . . . . . . . . . 14-19,14-55 CHARGING SYSTEM SPECIFICATIONS . . . . 8A-22
BREAKER, CIRCUIT . . . . . . . . . . . . . . . . 8S-1,8S-2 CANISTER, EVAP . . . . . . . . . . . . . . . . . . . . . 25-16 CHARGING TIME TABLE, BATTERY . . . . . . . . 8A-8
BREAK-IN, ENGINE . . . . . . . . . . . . . . . . . . . . 0-13 CANISTER PURGE SOLENOID, EVAP; CHASSIS AND BODY COMPONENTS . . . . . . . 0-24
BREATHER/FILTER—5.2L ENGINES, EMISSION CONTROL SYSTEMS . . . . . . . . . 25-17 CHASSIS COMPONENT AND WHEEL
CRANKCASE . . . . . . . . . . . . . . . . . . . . . . . . 25-10 CANISTER PURGE SOLENOID, EVAP; BEARING LUBRICANTS . . . . . . . . . . . . . . . . . 0-24
BUCKET SEAT CUSHION AND COVER . . . . . 23-30 FUEL SYSTEM . . . . . . . . . . . . . . . . . . . . . . . 14-87
. CHECK VALVE SERVICE, CONVERTER
BUCKET SEATBACK COVER AND FRAME . . 23-31 CANISTER PURGE SOLENOID—DUTY DRAINBACK . . . . . . . . . . . . . . . . . . . 21-213,21-86
BUCKET SEATS, FRONT . . . . . . . . . . . . . . . . 23-30 CYCLE, EVAP . . . . . . . . . . . . . . . . . . . . . . . . 25-17 CHECK VALVE TEST, POWER BRAKE
BULB APPLICATION . . . . . . . . . . . . . . . . . . . 8L-23 CANISTER PURGE SOLENOID—PCM BOOSTER . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-8
BULB, DOME LAMP . . . . . . . . . . . . . . . . . . . 8L-13 OUTPUT, EVAP . . . . . . . . . . . . . . . . . . . . . . . 14-60 CHECKING FRONT ROTOR THICKNESS . . . . . 5-48
BULB, MINI OVERHEAD CONSOLE CAP AND ROTOR, IGNITION CABLES, CHECKING REAR ROTOR LATERAL
READING LAMP . . . . . . . . . . . . . . . . . . . . . . 8L-14 DISTRIBUTOR . . . . . . . . . . . . . . . . . . . . . . . . 0-18 RUNOUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-50
BULB, OVERHEAD CONSOLE READING CAP, DISTRIBUTOR . . . . . . . . . . . . . . . . . . . . 8D-8 CHECKING REAR ROTOR THICKNESS . . . . . . 5-49
LAMP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8L-13 CAP, FUEL TANK FILLER TUBE; CHILD SEAT MODULE . . . . . . . . . . . . . . . . . 23-32
BULB REMOVE/INSTALL, READING/ EMISSION CONTROL SYSTEMS . . . . . 25-18,25-7 CHILD SEAT, REAR SEAT BACK WITH . . . . . 23-32
COURTESY LAMP . . . . . . . . . . . . . . . . . . . . 8C-11 CAP, FUEL TANK FILLER TUBE; FUEL CHIME MODULE . . . . . . . . . . . . . . . . . . . . . . 8U-1
BULB/LENS REPLACEMENT, PARKING SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14-12 CHIME WARNING SYSTEM . . . . . . . . . . . . . . 8U-3
LAMP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8L-7 CAP, RADIATOR PRESSURE . . . . . . . . . . . . . 7-28 CHIME/BUZZER MODULE . . . . . . . . . . . . 8W-44-2
BUMPER FASCIA, REAR . . . . . . . . . . . . . . . . 13-6 CAPACITIES, A/C REFRIGERANT OIL . . . . . . 24-10 CHMSL LAMPS, STOP LAMPS . . . . . . . . 8W-51-1
BUMPER, REAR . . . . . . . . . . . . . . . . . . . . . . . 13-5 CAPACITIES, COOLING SYSTEM . . . . . . . . . . 7-50 CHRYSLER COLLISION DETECTION BUS . . 24-26
BUMPER/FASCIA, FRONT . . . . . . . . . . . . . . . 13-4 CAPACITIES, FLUID . . . . . . . . . . . . . . . . . . . . . 0-3 CIGAR LIGHTER . . . . . . . . . . . . . . . . . . . 8W-41-1
BUMPERS . . . . . . . . . . . . . . . . . . . . . . . . . . . 13-4 CAPACITIES, FUEL TANK . . . . . . . . . . 14-12,14-95 CIRCUIT, AIR INLET/RECIRC DOOR
BURNED FLUID, CAUSES OF . . . . . . 21-171,21-43 CAPACITY TEST, FUEL PUMP . . . . . . . . . . . . 14-5 ACTUATOR DRIVE . . . . . . . . . . . . . . . . . . . . 24-24
BUS, CCD . . . . . . . . . . . . . . . . . . . . . . . . 8W-30-5 CARDAN, DOUBLE . . . . . . . . . . . . . . . . . . . . 16-12 CIRCUIT, BLEND AIR DOOR ACTUATOR
BUS, CHRYSLER COLLISION DETECTION . . 24-26 CARDAN, SINGLE . . . . . . . . . . . . . . . . . . . . 16-10 DRIVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24-24
BUSHING, DISTRIBUTOR . . . . . . . . . . . . . . . 9-62 CARDAN U-JOINT, AXLE SHAFT— . . . . . . . . 2-20 CIRCUIT BREAKER . . . . . . . . . . . . . . . . 8S-1,8S-2
BUSHING REPLACEMENT, AXLE . . . . . . . 2-26,2-9 CARGO LAMP/BULB . . . . . . . . . . . . . . . . . . 8L-14 CIRCUIT DIAGNOSIS, IGNITION
BUSHINGS, CLUTCH AND BRAKE PEDAL . . . 0-20 CARPETS AND FLOOR MATS . . . . . . . . . . . 23-41 SECONDARY . . . . . . . . . . . . . . . . . . . . . . . . 8D-10
BUSHINGS, LOWER AND UPPER CASE (4WD VEHICLES), TRANSFER . . . . . . . 0-22 CIRCUIT IDENTIFICATION . . . . . . . . . . . . . . . . 8-1
SUSPENSION ARM . . . . . . . . . . . . . . . . . . . . 0-24 CASE ASSEMBLY AND ADJUSTMENT, CIRCUIT, MODE DOOR ACTUATOR DRIVE . 24-24
BYPASS HOSE—5.2L V-8 ENGINE, TRANSFER . . . . . . . . . . . . . . . . . . . . . . . . . 21-360 CIRCUIT REMOVE/INSTALL, PRINTED . . . . 8E-24
WATER PUMP . . . . . . . . . . . . . . . . . . . . . . . . 7-18 CASE ASSEMBLY, OVERDRIVE CIRCUIT SENSE—PCM INPUT,
CABLE, ACCELERATOR PEDAL AND GEARTRAIN . . . . . . . . . . . . . . . . . . . . . . . . 21-286 IGNITION . . . . . . . . . . . . . . . . . . . . 14-21,14-56
THROTTLE . . . . . . . . . . . . . . . . 14-15,14-46,14-86 CASE ASSEMBLY, TRANSFER . . . . 21-303,21-329 CIRCUIT TESTING . . . . . . . . . . . . . . . . . . . . 24-22
CABLE ADJUSTMENT, GEARSHIFT . 21-206,21-79 CASE CHANGES, TRANSFER . . . . . 21-316,21-344 CIRCUIT TESTING (CONT.) . . . . . . . . . . . . . 24-23
CABLE ADJUSTMENT, PARK INTERLOCK . 21-207, CASE CLEANING AND INSPECTION, CIRCUIT VOLTAGE, OPEN . . . . . . . . . . . . . . . 8A-7
21-79 TRANSMISSION . . . . . . . . . . . . . . . 21-105,21-230 CIRCUITS, ELECTRICAL . . . . . . . . . . . . . . . . 24-24
CABLE ADJUSTMENT, TRANSMISSION CASE COVER OIL SEAL REPLACEMENT, CIRCUITS, VACUUM . . . . . . . . . . . . . . . . . . 24-14
THROTTLE VALVE . . . . . . . . . . . . . . 21-205,21-78 TIMING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-26 CLADDING, BODY SIDE . . . . . . . . . . . . . . . . . 23-8
CABLE ADJUSTMENTS, TRANSMISSION CASE COVER, TIMING . . . . . . . . . . . . . . . . . . 9-25 CLAMPS, FUEL TUBES/LINES/
CONTROL . . . . . . . . . . . . . . . . . . . . . . . . . 21-172 CASE DISASSEMBLY AND OVERHAUL, HOSES . . . . . . . . . . . . . . . . . . 14-49,14-90,14-7
CABLE, FUEL DOOR . . . . . . . . . . . . . . . . . . 23-41 TRANSFER . . . . . . . . . . . . . 21-297,21-321,21-348 CLASSIFICATION OF LUBRICANTS . . . . . . . . . 0-2
CABLE, LATCH RELEASE . . . . . . . . . . . . . . . . 23-5 CASE FILL LEVEL, TRANSFER . . . . . . . . . . 21-316 CLASSIFICATIONS AND RATINGS,
CABLE RESISTANCE, SPARK PLUG . 8D-15,8D-32 CASE IDENTIFICATION, ENGINE AND BATTERY . . . . . . . . . . . . . . . . . . . . . . . . . . . 8A-22
CABLE, SERVO . . . . . . . . . . . . . . . . . . . . . . . 8H-1 TRANSMISSION/TRANSFER . . . . . . . . . . . Intro.-4 CLEAN BRAKE FLUID, IMPORTANCE OF . . . . 5-15
CABLE, SPEEDOMETER . . . . . . . . . . . . . . . . . 0-27 CASE IDENTIFICATION, CLEANER ELEMENT, AIR; EMISSION
CABLE, THROTTLE . . . . . . . . . . . . . . . . . . . 14-15 TRANSFER . . . . . . . . . . 21-292,21-315,21-344 CONTROL SYSTEMS . . . . . . . . . . . . . . . . . . 25-15
CABLES, DISTRIBUTOR CAP AND CASE INSTALLATION, CLEANER ELEMENT, AIR; FUEL
ROTOR, IGNITION . . . . . . . . . . . . . . . . . . . . . 0-18 TRANSFER . . . . . . . . . . . 21-296,21-320,21-347 SYSTEM . . . . . . . . . . . . . . . . . . . . . 14-45,14-85
CASE LUBRICANT, TRANSFER . . . . . . . . . . 21-316 CLEANER ELEMENT, AIR; LUBRICATION
CABLES, DRIVE . . . . . . . . . . . . . . . . . . . . . . 23-13 CASE RANGE DISPLAY, AND MAINTENANCE . . . . . . . . . . . . . . . . . . . 0-16
CABLES, SPARK PLUG RANSFER . . . . . . . . . . . . . . . 8W-46-2,8W-46-3 CLEANER HOUSING, AIR; EMISSION
SECONDARY . . . . . . . . . . . . . . . . . 8D-14,8D-28 CASE REMOVAL, CONTROL SYSTEMS . . . . . . . . . . . . . . . . . . 25-15
CABLES, TRANSMISSION THROTTLE TRANSFER . . . . . . . . . . . 21-296,21-320,21-347 CLEANER HOUSING, AIR; FUEL
VALVE AND SHIFT . . . . . . . . . . . . . . . . . . . . 21-44 CASE SPECIFICATIONS, TRANSFER . . . . . 21-292 SYSTEM . . . . . . . . . . . . . . . . . . . . . 14-45,14-85
CALIBRATION AND CPU DATA . . . . . . . . . . 24-26 CASE SWITCHES, TRANSFER . . . . . . . . . . . 8E-21 CLEANING AND INSPECTION,
CALIBRATION, COMPASS . . . . . . . . . . . . . . . 8C-8 CATALYTIC CONVERTER; EMISSION COMPONENT . . . . . . . . . . . . . . . . . . . . . . . 21-357
CALIBRATION, TRIP COMPUTER FUEL CONTROL SYSTEMS . . . . . . . . . . . . . . . . . . 25-11 CLEANING AND INSPECTION,
SENDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8C-11 CATALYTIC CONVERTER; EXHAUST OVERDRIVE COMPONENT . . . . . . . 21-153,21-276
CALIPER ASSEMBLY, FRONT . . . . . . . . . . . . . 5-38 SYSTEM AND INTAKE MANIFOLD . . . . . 11-2,11-5 CLEANING/INSPECTION; FRONT
CALIPER ASSEMBLY, REAR . . . . . . . . . . . . . . 5-44 CCD BUS . . . . . . . . . . . . . . . . . . . . . . . . . 8W-30-5 SUSPENSION AND AXLE . . . . . . . . . . . . . . . . 2-29
CALIPER DISASSEMBLY AND CENTER HIGH MOUNTED STOP LAMP CLEANING/INSPECTION; REAR
OVERHAUL, FRONT . . . . . . . . . . . . . . . . . . . . 5-37 (CHMSL) . . . . . . . . . . . . . . . . . . . . . . . . . . . 8L-10 SUSPENSION AND AXLES . . . . . . . . . . . . . . . 3-16

4. 4 INDEX ZJ
Description Group-Page Description Group-Page Description Group-Page
CLEANING/REVERSE FLUSHING, COIL, IGNITION; IGNITION CONNECTOR, VIC . . . . . . . . . . . . . . . . . . . . 8E-18
COOLING SYSTEM . . . . . . . . . . . . . . . . . . . . 7-26 SYSTEMS . . . . . . . . . . . . . . . . 8D-25,8D-4,8D-9 CONNECTOR—PCM INPUT, DATA
CLEANUP PROCEDURE . . . . . . . . . . . . . . . . 8M-4 COIL RESISTANCE, IGNITION . . . . . . 8D-10,8D-33 LINK . . . . . . . . . . . . . . . . . . . . . . . 14-19,14-55
CLEARANCE AND RAMP ANGLE, COIL SPRING; FRONT SUSPENSION AND CONNECTOR—PCM OUTPUT, DATA
GROUND . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0-11 AXLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-10 LINK . . . . . . . . . . . . . . . . . . . . . . . 14-24,14-60
CLIP, FUEL LINE WITH LATCH . . . . . . . . . . 14-10 COIL SPRING; REAR SUSPENSION AND CONNECTORS, AUDIO SYSTEM . . . . . . . . . . 8F-4
CLOCKSPRING; RESTRAINT SYSTEMS . . . . 8M-2 AXLES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-4 CONNECTORS, TERMINAL/CONNECTOR
CLOCKSPRING; STEERING . . . . . . . . . . . . . 19-37 COIL TESTS, CLUTCH . . . . . . . . . . . . . . . . . 24-16 REPAIR—MOLEX . . . . . . . . . . . . . . . . . . . . . . 8-6
CLOCKSPRING CENTERING . . . . . . . . . . . . . 8M-8 COIL—PCM OUTPUT, IGNITION . . . . 14-25,14-61 CONSOLE, FULL FLOOR . . . . . . . . . . . . . . . 23-40
CLOCKSPRING REMOVE/INSTALL . . . . . . . . 8M-7 COLD CRANKING SPECIFICATIONS, CONSOLE LAMPS, OVERHEAD . . . . . . . . 8W-44-2
CLUSTER ILLUMINATION LAMPS . . . . 8E-11,8E-3 STARTING SYSTEM . . . . . . . . . . . . . . . . . . . 8A-22 CONSOLE, MINI OVERHEAD . . . . . . . . . . . . 8L-14
CLUSTER ILLUMINATION LAMPS, COLLISION DAMAGE . . . . . . . . . . . . . . . . . . . 13-1 CONSOLE, OVERHEAD . . . . . . . . . . . . . . . . . 8L-13
INSTRUMENT . . . . . . . . . . . . . . . . . . . . . 8W-40-1 COLLISION DETECTION BUS, CHRYSLER . . 24-26 CONSOLE READING LAMP BULB, MINI
CLUSTER, INSTRUMENT; INSTRUMENT COLUMN ASSEMBLY REPLACEMENT . . . . . 19-37 OVERHEAD . . . . . . . . . . . . . . . . . . . . . . . . . 8L-14
CLUSTER . . . . . . . . . . . . . . . . . . . . . . . . . 8W-40-1 COLUMN COMPONENT SERVICE . . . . . . . . 19-39 CONSOLE READING LAMP BULB,
CLUSTER, INSTRUMENT; INSTRUMENT COLUMN, STEERING . . . . . . . . . . . . . 19-35,19-42 OVERHEAD . . . . . . . . . . . . . . . . . . . . . . . . . 8L-13
PANEL AND GAUGES . . . . . . . . . . . . . . . . . . 8E-9 COMBINATION FLASHER REMOVE/ CONSOLE REMOVE/INSTALL, OVERHEAD . . . 8C-9
CLUSTER REMOVE/INSTALL, INSTALL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8J-5 CONSTANT VELOCITY JOINT . . . . . . . . . . . . 16-10
INSTRUMENT . . . . . . . . . . . . . . . . . . . . . . . 8E-22 COMBINATION VALVE . . . . . . . . . . . . . . . . . . 5-12 CONTACT PATTERN ANALYSIS,
CLUSTERS, INSTRUMENT . . . . . . . . . . . . . . . 8E-1 COMBINATION VALVE INSTALLATION . . . . . . 5-20 BACKLASH; REAR SUSPENSION AND
CLUTCH / COIL ASSEMBLY, COMBINATION VALVE REMOVAL . . . . . . . . . 5-20 AXLES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-23
COMPRESSOR . . . . . . . . . . . . . . . . . . . . . . . 24-29 COMBUSTION PRESSURE LEAKAGE CONTINUITY (LEFT), POWER SEAT
CLUTCH AND BAND OPERATION, AIR TEST, CYLINDER . . . . . . . . . . . . . . . . . . . . . . . 9-7 SWITCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8R-2
TESTING TRANSMISSION . . . . . . . . 21-176,21-48 COMPACT DISC PLAYERS, CHART F — CONTINUITY (RIGHT), POWER SEAT
CLUTCH AND BRAKE PEDAL BUSHINGS . . . 0-20 ALL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8F-11 SWITCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8R-3
CLUTCH AND GEARTRAIN ASSEMBLY, COMPASS . . . . . . . . . . . . . . . . . . . . . . . . . . . 8C-1 CONTROL AND DISPLAY SYMBOLS,
DIRECT . . . . . . . . . . . . . . . . . . . . . . . . . . . 21-281 COMPASS CALIBRATION . . . . . . . . . . . . . . . . 8C-8 INTERNATIONAL . . . . . . . . . . . . . . . . . . . . Intro.-6
CLUTCH COIL TESTS . . . . . . . . . . . . . . . . . . 24-16 COMPASS DEMAGNETIZING . . . . . . . . . . . . . 8C-8 CONTROL AND DISPLAY SYMBOLS,
CLUTCH COMPONENT LUBRICATION . . . . . . . 6-2 COMPASS VARIATION ADJUSTMENT . . . . . . . 8C-8 INTERNATIONAL VEHICLE . . . . . . . . . . . . . Intro.-4
CLUTCH COMPONENTS . . . . . . . . . . . . . . . . . . . 6-1 COMPENSATION, CALIPER OPERATION CONTROL (ATC) MODULE, AUTOMATIC
CLUTCH, COMPRESSOR . . . . . . . . . . . . . . . 24-14 AND WEAR . . . . . . . . . . . . . . . . . . . . . . . . . . 5-33 TEMPERATURE . . . . . . . . . . . . . . . . . . . . 8W-42-3
CLUTCH CONTAMINATION . . . . . . . . . . . . . . . 6-3 COMPENSATION, REAR CALIPER CONTROL, AUTOMATIC TEMPERATURE . 8W-42-3
CLUTCH CONTROL, CONVERTER . . . . . . . 21-168 OPERATION AND WEAR . . . . . . . . . . . . . . . . 5-41 CONTROL CABLE ADJUSTMENTS,
CLUTCH COVER AND DISC COMPLAINT, HISS NOISE . . . . . . . . . . . . . . . 19-3 TRANSMISSION . . . . . . . . . . . . . . . . . . . . . 21-172
INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . 6-10 COMPRESSION PRESSURE TEST, CONTROL, CONVERTER CLUTCH . . . . . . . 21-168
CLUTCH COVER AND DISC REMOVAL . . . . . 6-10 CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-6 CONTROL DIAGNOSTIC TROUBLE CODE,
CLUTCH COVER AND DISC RUNOUT . . . . . . . 6-3 COMPRESSOR . . . . . . . . . . . . . . . . . . . . . . . 24-27 SPEED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8H-6
CLUTCH DIAGNOSIS . . . . . . . . . . . . . . . . . . . . 6-3 COMPRESSOR, AIR CONDITIONING . . . . . . 24-44 CONTROL, EGR VALVE . . . . . . . . . . . . . . . . 25-16
CLUTCH DIAGNOSIS, COMPRESSOR . . . . . 24-28 COMPRESSOR, AIR-CONDITIONER . . . . . . . . 0-19 CONTROL, FRONT PANEL BLOWER/FAN . . . 24-25
CLUTCH ENGAGEMENT, CONVERTER . . . . . 21-40 COMPRESSOR AND CLUTCH DIAGNOSIS . . 24-28 CONTROL, FRONT PANEL MODE . . . . . . . . 24-24
CLUTCH HOUSING INSTALLATION . . . . . . . . 6-11 COMPRESSOR CLUTCH . . . . . . . . . . . . . . . 24-14 CONTROL, FUEL PUMP ELECTRICAL . . . . . . 14-4
CLUTCH HOUSING MISALIGNMENT . . . . . . . . 6-4 COMPRESSOR CLUTCH / COIL CONTROL (IAC) MOTOR, IDLE AIR; FUEL
CLUTCH HOUSING REMOVAL . . . . . . . . . . . . 6-11 ASSEMBLY . . . . . . . . . . . . . . . . . . . . . . . . . . 24-29 SYSTEM . . . . . . . . . . . . . . . . . . . . . . 14-49,14-90
CLUTCH HYDRAULIC LINKAGE COMPRESSOR DISCHARGE PRESSURE . . . . 24-9 CONTROL (IAC) MOTOR, IDLE AIR;
INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . 6-12 COMPRESSOR HIGH-PRESSURE RELIEF FUEL/IGNITION . . . . . . . . . . . . . . . . . . . . 8W-30-3
CLUTCH HYDRAULIC LINKAGE REMOVAL . . 6-12 VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24-30 CONTROL (IAC) MOTOR TEST, IDLE AIR . . 14-75
CLUTCH INSTALLATION AND COMPRESSOR MANIFOLD . . . . . . . . . . . . . 24-27 CONTROL (IAC) MOTOR—PCM OUTPUT,
ADJUSTMENT, OVERDRIVE . . . . . . . . . . . . 21-288 COMPRESSOR NOISE, A/C . . . . . . . . . . . . . 24-27 IDLE AIR . . . . . . . . . . . . . . . . . . . . . . 14-23,14-59
CLUTCH LINKAGE FLUID . . . . . . . . . . . . . . . . . 6-1 COMPRESSOR SERVICE . . . . . . . . . . . . . . . 24-27 CONTROL INFORMATION (VECI) LABEL,
CLUTCH, LOW-REVERSE DRUM AND COMPUTER FUEL SENDER VEHICLE EMISSION . . . . . . . . . . . . . . . . . . . . 25-1
OVERDRIVE PISTON RETAINER CALIBRATION, TRIP . . . . . . . . . . . . . . . . . . 8C-11 CONTROL MODULE (ACM), AIRBAG . . . . 8W-43-1
INSPECTION AND OVERHAUL, COMPUTER REMOVE/INSTALL, TRIP . . . . . 8C-10 CONTROL MODULE, AIRBAG . . . . . . . . . . . . 8M-2
OVERRUNNING . . . . . . . . . . . . . . . . . . . . . 21-105 COMPUTER, TRIP . . . . . . . . . . . . . . . . . . . . . 8C-1 CONTROL MODULE (PCM) 60-WAY
CLUTCH MASTER CYLINDER . . . . . . . . . . . . 0-20 COMPUTER/COMPASS/DISPLAY CONNECTOR, POWERTRAIN . . . . . . . 14-32,14-69
CLUTCH MISALIGNMENT . . . . . . . . . . . . . . . . 6-3 SELF-DIAGNOSTIC TEST, TRIP . . . . . . . . . . . 8C-2 CONTROL MODULE (PCM),
CLUTCH OPERATION . . . . . . . . . . . . . . . . . . . . 6-2 CONDENSER . . . . . . . . . . . . . . . . . . . . . . . . 24-41 POWERTRAIN; EMISSION CONTROL
CLUTCH OVERHAUL, FRONT . . . . . 21-110,21-238 CONDITIONING (A/C) CLUTCH RELAY, SYSTEMS . . . . . . . . . . . . . . . . . . . . . . . . . . 25-18
CLUTCH OVERHAUL, OVERRUNNING . . . . 21-231 AIR . . . . . . . . . . . . . . . . . . . . . . . . . . 14-46,14-86 CONTROL MODULE (PCM),
CLUTCH OVERHAUL, REAR . . . . . . 21-112,21-240 CONDITIONING (A/C) CLUTCH POWERTRAIN; FUEL
CLUTCH PEDAL INSTALLATION . . . . . . . . . . 6-13 RELAY—PCM OUTPUT, AIR . . . . . . . 14-23,14-59 SYSTEM . . . . . . . . . . 14-18,14-50,14-54,14-91
CLUTCH PEDAL POSITION SWITCH . . . . . . . . 6-1 CONDITIONING (A/C) CONTROLS—PCM CONTROL MODULE (PCM),
CLUTCH PEDAL REMOVAL . . . . . . . . . . . . . . 6-13 INPUT, AIR . . . . . . . . . . . . . . . . . . . . 14-19,14-55 POWERTRAIN; IGNITION
CLUTCH RELAY, AIR CONDITIONING CONDITIONING COMPRESSOR, AIR . . . . . . 24-44 SYSTEMS . . . . . . . . . . . . . . . 8D-12,8D-26,8D-5
(A/C) . . . . . . . . . . . . . . . . . . . . . . . . . 14-46,14-86 CONDITIONING CYCLING SWITCH, AIR . . . 24-16 CONTROL MODULE, POWERTRAIN . . . 8H-1,8H-7
CLUTCH RELAY—PCM OUTPUT, AIR CONDITIONING OPERATION, CONTROL MODULE REMOVE/INSTALL,
CONDITIONING (A/C) . . . . . . . . . . . . . 14-23,14-59 AIR . . . . . . . . . . . . . . . . . . . . 8W-42-1,8W-42-3 AIRBAG . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8M-6
CLUTCH SERVICE . . . . . . . . . . . . . . . . . . . . . 6-10 CONNECTING ROD ASSEMBLY, PISTON . . . . 9-69 CONTROL MODULE (TCM) SERVICE,
CLUTCH (TCC) SOLENOID—5.2L CONNECTING ROD BEARING FITTING TRANSMISSION . . . . . . . . . . . . . . . . . . . . . . 21-84
ENGINE, OVERDRIVE SOLENOID AND CHART . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-36 CONTROL MODULE—4.0L ENGINE,
TORQUE CONVERTER . . . . . . . . . . . . . . . 8W-31-1 CONNECTING RODS, PISTONS . . . . . . . . . . . 9-34 TRANSMISSION . . . . . . . . . . . . . . . . . . . 8W-31-1
CODE DECODING, BODY . . . . . . . . . . . . . . Intro.-4 CONNECTOR, ABS DIAGNOSTIC . . . . . . . 5-11,5-3 CONTROL MOTOR TEST, IDLE AIR . . . . . . . 14-36
CODE (DTC), DIAGNOSTIC TROUBLE . . . . . 14-41, CONNECTOR AND TERMINAL CONTROL SERVO REMOVE/INSTALL,
REPLACEMENT . . . . . . . . . . . . . . . . . . . . . . . . 8-7 SPEED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8H-9
14-81 CONNECTOR, DATA LINK; AIRBAG CONTROL SERVO, SPEED . . . . . . . . . . 8H-1,8H-6
CODE, GENERATOR DIAGNOSTIC SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . 8W-43-1 CONTROL SOLENOID—PCM OUTPUT,
TROUBLE . . . . . . . . . . . . . . . . . . . . . . . . . . . 8A-21 CONNECTOR, DATA LINK; ANTI-LOCK EGR (EXHAUST GAS RECIRCULATION)
CODE IDENTIFICATION, WIRE . . . . . . . . . . . . . 8-1 BRAKES . . . . . . . . . . . . . . . . . . . . . . . . . 8W-32-2 VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14-60
CODE PLATE, BODY . . . . . . . . . . . . . . . . . Intro.-3 CONNECTOR, DATA LINK; FUEL/IGNITION . 8W-30-5 CONTROL SWITCH REMOVE/INSTALL,
CODE, SPEED CONTROL DIAGNOSTIC CONNECTOR, LAMP OUTAGE MODULE . . . . 8E-18 SPEED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8H-9
TROUBLE . . . . . . . . . . . . . . . . . . . . . . . . . . . 8H-6 CONNECTOR LOCATIONS; CONNECTOR CONTROL SWITCH, SPEED . . . . . . . . . 8H-1,8H-3
CODES AND DIMENSIONS/WEIGHTS, LOCATIONS . . . . . . . . . . . . . . . . . . . . . . . 8W-90-1 CONTROL SYSTEM, EMISSION . . . . . . . . . . . 0-19
DESIGNATIONS, LABELS/PLATES/ CONNECTOR LOCATIONS; CONNECTOR CONTROL SYSTEM, EVAP
DECALS . . . . . . . . . . . . . . . . . . . . . . . . . . . Intro.-1 PIN OUTS . . . . . . . . . . . . . . . . . . . . . . . . 8W-80-1 (EVAPORATION) . . . . . . . . . . . . . . . . . . . . . . 25-5
CODES, DIAGNOSTIC TROUBLE FLASH . . . 21-44 CONNECTOR LOCATIONS; WIRING CONTROL SYSTEM, HYDRAULIC . . . . . . . 21-167
COIL ASSEMBLY, COMPRESSOR DIAGRAMS . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-1 CONTROL SYSTEM MAINTENANCE,
CLUTCH / . . . . . . . . . . . . . . . . . . . . . . . . . 24-29 CONNECTOR, POWERTRAIN CONTROL EMISSION . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0-4
COIL, IGNITION; FUEL SYSTEM . . . . 14-49,14-90 MODULE (PCM) 60-WAY . . . . . . . . . . 14-32,14-69 CONTROL UNIT (ECU), ELECTRONIC . . . . . . 5-11
COIL, IGNITION; FUEL/IGNITION . . . . . . . 8W-30-2 CONNECTOR REPLACEMENT . . . . . . . . . . . . . 8-6 CONTROL UNIT (HCU), HYDRAULIC . . . . . . . 5-10

5. ZJ INDEX 5
Description Group-Page Description Group-Page Description Group-Page
CONTROL UNIT, HYDRAULIC . . . . . . . . . 8W-32-2 CORE, EVAPORATOR . . . . . . . . . . . . . . . . . . 24-35 CYLINDER HEAD GASKET FAILURE
CONTROL, VACUUM . . . . . . . . . . . . . . . . . . 24-13 CORE, HEATER . . . . . . . . . . . . . . . . . . . . . . 24-35 DIAGNOSIS, ENGINE . . . . . . . . . . . . . . . . . . . . 9-6
CONTROL, VEHICLE SPEED . . . . . . . . . . 8W-33-1 COUPLING, INTERMEDIATE SHAFT . . . . . . . 19-21 CYLINDER HEADS . . . . . . . . . . . . . . . . . . . . . 9-53
CONTROL—PCM INPUT, SPEED . . . . 14-22,14-58 COURTESY LAMP, DOOR . . . . . . . . . . . . . . . 8L-14 DAMAGED OR WORN THREADS, REPAIR . . . . 9-4
CONTROL—PCM OUTPUT, SPEED . . 14-25,14-61 COURTESY LAMPS, READING . . . . . . . . . . . 8C-2 DAMPENER, STEERING . . . . . . . . . . . . . . . . 19-16
CONTROLS, EVAPORATIVE EMISSION . . . . . 25-5 COVER AND DISC INSTALLATION, DAMPER, VIBRATION . . . . . . . . . . . . . . 9-25,9-58
CONTROLS, EXHAUST EMISSION . . . . . . . . 25-11 CLUTCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-10 DATA, CALIBRATION AND CPU . . . . . . . . . . 24-26
CONTROLS, OVERDRIVE COVER AND DISC REMOVAL, CLUTCH . . . . . 6-10 DATA LINK CONNECTOR; AIRBAG
ELECTRICAL . . . . . . . . . . . . . . . . 21-171,21-43 COVER AND DISC RUNOUT, CLUTCH . . . . . . . 6-3 SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . 8W-43-1
CONTROLS—PCM INPUT, AIR COVER AND FRAME, BUCKET SEATBACK . . 23-31 DATA LINK CONNECTOR; ANTI-LOCK
CONDITIONING (A/C) . . . . . . . . . . . . . 14-19,14-55 COVER, BUCKET SEAT CUSHION . . . . . . . . 23-30 BRAKES . . . . . . . . . . . . . . . . . . . . . . . . . 8W-32-2
CONVERSION FORMULAS AND COVER, CYLINDER HEAD . . . . . . . . . . . . . . . 9-52 DATA LINK CONNECTOR; FUEL/
EQUIVALENT VALUES . . . . . . . . . . . . . . . . Intro.-7 COVER, D-PILLAR TRIM . . . . . . . . . . . . . . . 23-35 IGNITION . . . . . . . . . . . . . . . . . . . . . . . 8W-30-5
CONVERSION, METRIC . . . . . . . . . . . . . . Intro.-12 COVER, ENGINE CYLINDER HEAD . . . . . . . . 9-17 DATA LINK CONNECTOR—PCM
CONVERSION, METRIC AND ENGLISH/ COVER OIL SEAL REPLACEMENT, INPUT . . . . . . . . . . . . . . . . . . . . . . 14-19,14-55
SAE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Intro.-7 TIMING CASE . . . . . . . . . . . . . . . . . . . . . . . . 9-26 DATA LINK CONNECTOR—PCM
CONVERTER AND DRIVE PLATE COVER, REAR SEAT CUSHION . . . . . . . . . . 23-31 OUTPUT . . . . . . . . . . . . . . . . . . . . . 14-24,14-60
SERVICE, TORQUE . . . . . . . . . . . . . 21-217,21-90 COVER, REAR SEATBACK . . . . . . . . . . . . . . 23-32 DAY/NIGHT MIRROR . . . . . . . . . . . . . . . . 8W-44-2
CONVERTER, CATALYTIC; EMISSION COVER REPLACEMENT, PITMAN SHAFT DAY/NIGHT MIRROR, AUTOMATIC . . . . 8T-1,8T-2
CONTROL SYSTEMS . . . . . . . . . . . . . . . . . . 25-11 AND SIDE . . . . . . . . . . . . . . . . . . . . . . . . . . 19-26 DAY/NIGHT MIRROR REMOVE/INSTALL,
CONVERTER, CATALYTIC; EXHAUST COVER, TIMING CASE . . . . . . . . . . . . . . . . . . 9-25 AUTOMATIC . . . . . . . . . . . . . . . . . . . . . . . . . . 8T-6
SYSTEM AND INTAKE MANIFOLD . . . . . 11-2,11-5 COVER, TIMING CHAIN . . . . . . . . . . . . . . . . . 9-58 DAYTIME RUNNING LAMPS MODULE . . 8W-50-2
CONVERTER CLUTCH CONTROL . . . . . . . . 21-168 COVERS, B AND C-PILLAR TRIM . . . . . . . . 23-35 DAYTIME RUNNING LIGHT MODULE . . . . . 8L-16
CONVERTER CLUTCH ENGAGEMENT . . . . . 21-40 COWL GRILLE AND SCREEN . . . . . . . . . . . . . 23-5 DECODING, BODY CODE . . . . . . . . . . . . . . Intro.-4
CONVERTER CLUTCH (TCC) C-PILLAR TRIM COVERS, B . . . . . . . . . . . . 23-35 DEFOGGER RELAY . . . . . . . . . . . . . . . . . . . . 8N-2
SOLENOID—5.2L ENGINE, OVERDRIVE CPU DATA, CALIBRATION . . . . . . . . . . . . . . 24-26 DEFOGGER RELAY/TIMER . . . . . . . . . . . . . . . 8N-1
SOLENOID AND TORQUE . . . . . . . . . . . . 8W-31-1 CRANKCASE BREATHER/FILTER—5.2L DEFOGGER RELAY/TIMER REMOVE/
CONVERTER DIAGNOSIS, TORQUE . . . . . 21-191, ENGINES . . . . . . . . . . . . . . . . . . . . . . . . . . . 25-10 INSTALL . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8N-7
21-192,21-193,21-63,21-64,21-65 CRANKCASE VENTILATION SYSTEM . . . . . . . 0-16 DEFOGGER SWITCH . . . . . . . . . . . . . . . 8N-1,8N-2
CONVERTER DRAINBACK CHECK VALVE CRANKCASE VENTILATION SYSTEM— DEFOGGER SWITCH REMOVE/INSTALL . . . . 8N-4
SERVICE. . . . . . . . . . . . . . . . . . . . . . 21-213,21-86
. 4.0L 6-CYLINDER ENGINE . . . . . . . . . . . . . . . 25-7 DEFOGGER SYSTEM SCHEMATIC, REAR
CONVERTER DRAINBACK VALVE . . . 21-168,21-40 CRANKCASE VENTILATION SYSTEM— WINDOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8N-3
CONVERTER HOUSING FLUID LEAK 5.2L V-8 ENGINE, POSITIVE . . . . . . . . . . . . . 25-7 DEFROST AND PANEL / DEFROST DOOR
DIAGNOSIS . . . . . . . . . . . . . . . . . . . 21-176,21-49 CRANKING SPECIFICATIONS, STARTING MOTOR, HEAT / . . . . . . . . . . . . . . . . . . . . . . 24-38
CONVERTER INSTALLATION, SYSTEM COLD . . . . . . . . . . . . . . . . . . . . . . 8A-22 DEFROST DOOR ACTUATOR, HEAT / . . . . . . 24-37
TRANSMISSION . . . . . . . . . . . . . . . . . . . . . 21-217 CRANKSHAFT . . . . . . . . . . . . . . . . . . . . . . . . 9-70 DEFROST DOOR ACTUATOR, PANEL / . . . . 24-39
CONVERTER REMOVAL, TRANSMISSION . 21-216 CRANKSHAFT MAIN BEARINGS . . . . . . 9-40,9-71 DEFROST DOOR, HEAT / . . . . . . . . . . . . . . . 24-38
CONVERTER STALL TEST . . . . . . . . 21-175,21-47 CRANKSHAFT OIL SEAL REPLACEMENT, DEFROST DOOR MOTOR, HEAT /
CONVERTER, TORQUE . . . . . . . . . . . 21-164,21-38 FRONT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-60 DEFROST AND PANEL / . . . . . . . . . . . . . . . . 24-38
COOLANT . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-23 CRANKSHAFT POSITION SENSOR; FUEL DEFROST DOOR, PANEL / . . . . . . . . . . . . . . 24-39
COOLANT LEVEL SENSOR REMOVE/ SYSTEM . . . . . . . . . . . . . . . . . . . . . . 14-47,14-87 DEFROSTER DUCT . . . . . . . . . . . . . . . . . . . 24-41
INSTALL . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8E-29 CRANKSHAFT POSITION SENSOR; DELIVERY SYSTEM, FUEL . . . . . . . . . . . . . . . 14-3
COOLANT RESERVE/OVERFLOW SYSTEM . . 7-28 FUEL/IGNITION . . . . . . . . . . . . . . . . . . . . 8W-30-3 DEMAGNETIZING, COMPASS . . . . . . . . . . . . 8C-8
COOLANT ROUTING, SYSTEM . . . . . . . . . . . . . 7-2 CRANKSHAFT POSITION SENSOR; DEMISTERS, SIDE WINDOW . . . . . . . . . . . . . 24-1
COOLANT TEMPERATURE GAUGE, IGNITION SYSTEMS . . . . . . . . . . . . . . 8D-18,8D-2 DEPTH INFORMATION, PINION GEAR;
ENGINE . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-40-1 CRANKSHAFT POSITION SENSOR TEST; FRONT SUSPENSION AND AXLE . . . . . . . . . . 2-30
COOLANT TEMPERATURE SENSOR, FUEL SYSTEM . . . . . . . . . . . . . . . . . . 14-35,14-73 DEPTH INFORMATION, PINION GEAR;
ENGINE; EMISSION CONTROL CRANKSHAFT POSITION SENSOR TEST; REAR SUSPENSION AND AXLES . . . . . . . . . . 3-17
SYSTEMS . . . . . . . . . . . . . . . . . . . . . . . . . . 25-15 IGNITION SYSTEMS . . . . . . . . . . . . . . . . . . . 8D-7 DEPTH VARIANCE, PINION GEAR; FRONT
COOLANT TEMPERATURE SENSOR, CRANKSHAFT POSITION SENSOR—PCM SUSPENSION AND AXLE . . . . . . . . . . . . . . . . 2-31
ENGINE; FUEL SYSTEM . . . . . . . . . . . 14-47,14-87 INPUT . . . . . . . . . . . . . . . . . . . . . . . . 14-20,14-56 DEPTH VARIANCE, PINION GEAR; REAR
COOLANT TEMPERATURE SENSOR, CRANKSHAFT REAR OIL SEALS . . . . . . . . . . 9-72 SUSPENSION AND AXLES . . . . . . . . . . . . . . . 3-18
ENGINE; FUEL/IGNITION . . . . . . . . . . . . . 8W-30-4 CROSSMEMBER, RADIATOR SUPPORT . . . . 23-3 DESCRIPTION AND OPERATION . . . . . . . . . . 7-48
COOLANT TEMPERATURE SENSOR, CURVES, GOVERNOR PRESSURE . . . . . . . . 21-40 DESCRIPTION, SYSTEM . . . . . . . . . . . . . . . . 5-10
ENGINE; IGNITION SYSTEMS . . . . . . . 8D-20,8D-4 CUSHION AND COVER, BUCKET SEAT . . . . 23-30 DESCRIPTION, TRANSMISSION . . . 21-164,21-36
COOLANT TEMPERATURE SENSOR TEST, CUSHION COVER, REAR SEAT . . . . . . . . . . 23-31 DESCRIPTION, WHEEL . . . . . . . . . . . . . . . . 22-12
ENGINE; FUEL SYSTEM . . . . . . . . . . . 14-34,14-71 CUSHION, REAR SEAT . . . . . . . . . . . . . . . . . 23-31 DESCRIPTION/SYSTEM OPERATION,
COOLANT TEMPERATURE SENSOR TEST, CUT-OUT SWITCH, HIGH MULTI-PORT FUEL INJECTION
ENGINE; IGNITION SYSTEMS . . . . . . . . . . . 8D-10 PRESSURE . . . . . . . . . . . . . . . . . . 24-17,24-44 (MFI)—4.0L 6 CYL. ENGINE—
COOLANT TEMPERATURE SENSOR— CV-JOINT, AXLE SHAFT— . . . . . . . . . . . . . . . 2-21 COMPONENT . . . . . . . . . . . . . . . . . . . . . . . . 14-17
PCM INPUT, ENGINE . . . . . . . . . . . . . 14-21,14-56 CYCLE, EVAP CANISTER PURGE DESCRIPTION/SYSTEM OPERATION,
COOLANT WARNING, LOW ENGINE . . . . 8W-46-2 SOLENOID—DUTY . . . . . . . . . . . . . . . . . . . 25-17 MULTI-PORT FUEL INJECTION
COOLER FLOW TESTING, CYCLE EVAP PURGE SOLENOID—PCM (MFI)—5.2L V-8 ENGINE—
TRANSMISSION . . . . . . . . . . . . . . . . 21-213,21-87 OUTPUT, DUTY . . . . . . . . . . . . . . . . . . . . . . 14-24 COMPONENT . . . . . . . . . . . . . . . . . . . . . . . . 14-53
COOLER LINE AND FITTING SERVICE, CYCLING SWITCH, AIR CONDITIONING . . . 24-16 DESIGNATION, VEHICLE . . . . . . . . . . . . . . Intro.-1
TRANSMISSION . . . . . . . . . . . . . . . . 21-211,21-85 CYL. ENGINE—COMPONENT DESIGNATIONS, LABELS/PLATES/
COOLER REPLACEMENT, DESCRIPTION/SYSTEM OPERATION, DECALS, CODES AND DIMENSIONS/
TRANSMISSION . . . . . . . . . . . . . . 21-214,21-87 MULTI-PORT FUEL INJECTION WEIGHTS . . . . . . . . . . . . . . . . . . . . . . . . . Intro.-1
COOLER REVERSE FLUSHING, (MFI)—4.0L 6 . . . . . . . . . . . . . . . . . . . . . . . 14-17 DETECTION AND REPAIR, FIXED GLASS
TRANSMISSION . . . . . . . . . . . . . . . . 21-214,21-87 CYL. ENGINE—COMPONENT REMOVAL/ WATER LEAK . . . . . . . . . . . . . . . . . . . . . . . . 23-27
COOLERS, AUTOMATIC TRANSMISSION INSTALLATION, MULTI-PORT FUEL DETECTION BUS, CHRYSLER COLLISION . . 24-26
OIL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-38 INJECTION (MFI)—4.0L 6 . . . . . . . . . . . . . . 14-45 DEVICES, ELECTROSTATIC DISCHARGE
COOLING SYSTEM; COOLING SYSTEM . . . . . . 7-1 CYL. ENGINE—GENERAL DIAGNOSIS, (ESD) SENSITIVE . . . . . . . . . . . . . . . . . . . . . . . 8-2
COOLING SYSTEM; HEATING AND AIR MULTI-PORT FUEL INJECTION DIAGNOSIS; AUDIO SYSTEMS . . . . . . . . . . . 8F-3
CONDITIONING . . . . . . . . . . . . . . . . . . . . . . . 24-6 (MFI)—4.0L 6 . . . . . . . . . . . . . . . . . . . . . . . 14-29 DIAGNOSIS; BATTERY/STARTING/
COOLING SYSTEM CAPACITIES . . . . . . . . . . 7-50 CYLINDER BENCH BLEEDING, MASTER . . . . 5-23 CHARGING SYSTEMS DIAGNOSTICS . . . . . 8A-10,
COOLING SYSTEM CLEANING/REVERSE 8A-11,8A-17,8A-3
FLUSHING . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-26 CYLINDER BLOCK . . . . . . . . . . . . . . . . . 9-44,9-73 DIAGNOSIS; CHIME/BUZZER WARNING
COOLING SYSTEM COMPONENTS . . . . . . . . . 7-1 CYLINDER BORES, HONING . . . . . . . . . . . . . . 9-2 SYSTEMS . . . . . . . . . . . . . . . . . . . . . . . . . . . 8U-3
COOLING SYSTEM DIAGNOSIS . . . . . . . . . . . . 7-5 CYLINDER, CLUTCH MASTER . . . . . . . . . . . . 0-20 DIAGNOSIS; COOLING SYSTEM . . . . . . . . . . . 7-3
COOLING SYSTEM CYLINDER COMBUSTION PRESSURE DIAGNOSIS; HORNS . . . . . . . . . . . . . . . . . . . 8G-1
DIAGNOSIS (CONT.) . . . . . 7-10,7-6,7-7,7-8,7-9 LEAKAGE TEST . . . . . . . . . . . . . . . . . . . . . . . . 9-7 DIAGNOSIS; INSTRUMENT PANEL AND
COOLING SYSTEM, DRAINING . . . . . . . . . . . 7-25 CYLINDER COMPRESSION PRESSURE GAUGES . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8E-6
COOLING SYSTEM, ENGINE . . . . . . . . . . . . . 0-15 TEST . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-6 DIAGNOSIS; OVERHEAD CONSOLE . . . . . . . . 8C-2
COOLING SYSTEM FAN . . . . . . . . . . . . . . . . . 7-35 CYLINDER, DOOR KEY LOCK . . . . . . . . . . . 23-18 DIAGNOSIS; POWER LOCKS . . . . . . . . . . . . . 8P-2
COOLING SYSTEM FOR LEAKS, TESTING . . . 7-26 CYLINDER HEAD COVER . . . . . . . . . . . . . . . . 9-52 DIAGNOSIS; POWER MIRRORS . . . . . . . . . . 8T-2
COOLING SYSTEM HOSES . . . . . . . . . . . . . . 7-34 CYLINDER HEAD COVER, ENGINE . . . . . . . . 9-17 DIAGNOSIS; POWER SEATS . . . . . . . . . . . . . 8R-2
COOLING SYSTEM, REFILLING . . . . . . . . . . . 7-26 CYLINDER HEAD, ENGINE . . . . . . . . . . . . . . . 9-20 DIAGNOSIS; POWER WINDOWS . . . . . . . . . . 8S-2